Stress Analysis
‘The equations provided are usd to check that the lst sires init ofthe ing materi ne encoded by stress due to nstaliaton Standard parts that re
_assernbled manually inthe recommended shafvbore and groove dareters donot equestess analysis. Custom ngs. o rings beng assembled wth
‘stom toolng require ses ana
Toselet a sate sues value, is necesary 1 estimate the east ofthe raw materia The minimum tense Engh, mal Be@ €0,-0)
se hown inthe materals table ofthe catalog canbe ured as asutabe estimate Ash ny theoretcalcaleulsion,a "8 Bre,
daser als of the actual application ay reveal tat these sree values can be exceeded However, pace emitng e,-09
onideration must be made to funcona characteristics such a stallion metho, the numberof mes thering wl be 5
Installed and removed thrustload andor contuga capaty
‘er Fring thesis natural tendency st return ots gal stat. Ths places the ner edge ofthe rad alin residual tension and the outer gen
residual compression. To acount forthe residual stress nthe ing when expansion aking place, only DX ofthe minum ten tenth should be used
‘0 comparetotheinstallton ses; ee abe 4 n custom desl where thenstallaon ses exceeds the materia last nt rng can be produces to
lamers which wild a predetermined amount during assembly. Once instal the rng wl hav the proper cng onthe roo.
Nomenclature
Se=Sires due to expansion (ge)
‘c= Sess due to compression (ps)
= Modis of easy pa)
b= Racal wal)
ee Shaft lamer)
‘= Housing Diameter)
y= Freetnsdedamete, minum (o)
8
ree ouside ameter, enum r)