1) Press and retain pressed JH-TX 2740 1st button and at the same time press 4 times
the 2nd button.
2) Release both butions. So JH-7X 2740LED will emit a quick flash every 2 sec.
3) Place the ongina! remote control on the opposite of JH-TX 2740 (see Figure 1.).
4) Press and retain the bution to copy of the original re-mote coniro! and wait till the
LED of JH-TX 2740 changes the way to flash (fasten, it means that the code has been
fearnt, This may take a few seconds.
5) While the LED flashes, press JH-TX 2740 button where you want to store the code
just copied, until the LED switches off.
NOTE
if the procedure is not successful or some errors occur, please wait some second and
Start the procedure again from point 7
JH-TX 2740 memory is completely rewritable.
To program the others channels of JH-TX 2740, repeat the same procedure from the
beginning (paint 1).
Battery Type: 12V 234]