[e)
ICOM
SERVICE
MANUAL
WIDEBAND RECEIVER
IiC-—R7100
Icom Inc.INTRODUCTION
This service manual describes the latest service infor:
mation for the 1C-R7100 WIDEBAND RECEIVER at the
time of publication,
5 versions of the IC-R7100 have been designed. This
service manual covers each version
VERSION NO.[ VERSION | SYMBOL
B02 USA USA,
03 Europe eu
08 “Ausvalia AUS
B05 Germany |
B08 France FRA
To upgrade quality, all electrical er mechanical parte
‘and internal circuits are subject to change without
notice or obligation
DANGER
Use ONLY the specified AC voltage described on the
AC power socket. Other voltages will cause receiver
‘damage or personal injury.
DO NOT touch the REG UNIT after the receiver is
connected to an AC outlet. An insulated tool must be
used at all times,
DO NOT expose the receiver to rain, snow oF any liquids.
DO NOT apply an AF signal of more than 100 mW.
(20 dBm) to the antenna connector. This could damage
the receiver's front-end,
ORDERING PARTS
Be sure to include the following four points when ordering
replacement paris:
10-digt order numbers
‘Component part number and name
Equipment model name and unit name
‘Quantity required
1110001360 1¢yPCI2AAH—_ICATIOOMANUNIT Spices
fasr0003610 Screw FHMSX62K8S ICRTIOOTopcoer YOpieces
Addresses are provided on the inside back cover for your
convenience.
REPAIR NOTES
1, Make sure a problem is internal before disassembling
the receiver.
2 DO NOT open the receiver until the receiver is