Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Page 2
Page 3
References
Page 4
Page 5
DBS3800 Overview
DBS3800 is a distributed NodeB of Huawei
Technologies Co.Ltd.
DBS3800 system consists of:
Antenna TMA RF jumper
BBU3806
RRU3801C
RRU3801C
Antenna and feeder system
RNC
-48V DC/220V AC Feeder
Power cable
BBU3806
Grounding cable
RF jumper
+24V/-48V DC
Power cable
Page 6
DBS3800 Installation
Traditional outdoor macro NodeB
Difficult to transport and move Need large space to locate Require long feeder
DBS3800 Distributed NodeB
RRU
small dimensioning design RRU can be installed near antenna The numbers of BBU and RRU can be configured according to different requirements
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 7
BBU
DBS3800 Deployment
Application scenario 1
Page 8
DBS3800 Deployment
Application scenario 2
Page 9
DBS3800 Deployment
Application scenario 3:
Launch a new 3G indoor site, there is an equipment room but the space is limited and load-bearing capacity is week
Page 10
DBS3800 Deployment
Application scenario 4
Launching a new 3G outdoor site, the operator has no equipment room or fiber resources, or it is very hard to route optical fibers
Page 11
BBU3806
BBU3806C
RRU3801C
BTS3801C
Page 12
DBS3800 Characteristics
supports circuit domain (CS) and packet (PS) domain services supports positioning services supports softer handover, soft handover and hard handover Supports transmit diversity mode and receive diversity mode Supports high-speed downlink packet access (HSDPA) technology
HSDPA allows the traffic at up to 14.4 Mbps for a single cell HDSPA enables a single cell to support 15 OVSF codes
Supports RRU cascading
The maximum distance between two RRUs is 40km The distance from the first one to the last one should be within 100km When using the 1.25 G optical module, cascading levels is less than 4 When using the 2.5 G optical module, cascading levels is less than 8
Page 13
Page 14
Chapter2 Hardware Introduction Section1 Section2 Section3 Section4 BBU Hardware RRU Hardware BTS3801C Hardware Antenna and Feeder Subsystem
Page 15
BBU Overview
BBU3806 appearance
Index Dimension BBU3806
BBU3806Cappearance
BBU3806C
the housing )
Weight Power and Power Consumption CE Numbers 3kg -48V DC +24V DC 60W 60W 15kg 220V AC -48V DC 120W 100W
128CE(UL)/256CE(DL)(V17)
128CE(UL)/256CE(DL)(V17)
Cells
3
All rights reserved Page 16
Page 17
BBU3806 Panel
BITS GPS FE1 CPRI0 CPRI1 CPRI2 RUN ALM ACT EXT_ALM
BBU-RRU interface
Indicator
BBU-RNC interface
Page 18
T1
Iub Interface E3 T3 STM-1 Fast Ethernet Interface between BBU and RRU CPRI (optical port or electrical port) EIa EIb
8
2 2 2 2
1.5 Mbit/s
34.4 Mbit/s 44.7 Mbit/s 155 Mbit/s 100 Mbit/s 1.25 Gbit/s
Or 2.5 Gbit/s
1 1
32.5Gbit/s 32.5Gbit/s
Page 19
CPRI
CPRI Common Public Radio Interface
Page 20
BBU3806 Indicators
Name Color Status Flashing slowly at 0.5 Hz RUN green Flashing fast at 1Hz On Off ALM ACT LIU0 LIU7 red green Off On Meaning The BBU is working normally The BBU is loading Checkout status of the version or BBU is faulty There is no power input or the BBU is faulty Theres no alarmexclude VSWR warning Theres alarm exclude VSWR warning
On
Off Off On Flashing Off
green
CPRI0 CPRI2
green
On
Flashing
DIP position4
DIP position5
DIP position6
Meaning
OFF
ON OFF ON DIP position7 OFF
OFF
OFF ON ON
OFF
OFF OFF OFF DIP position8
OFF
OFF
ON ON
ON
OFF ON
100ohm T1
reserved 75ohm E1default value
Page 22
BBU3806C Panel
Maintenance Panel
RST
Bottom Panel
Distributed Board
RS485& EXT_ALM
RUN LIU0 10 M
PWR
CPRI2_TX CPRI2_RX
E1/T1&75/120 LOCAT.ID
ACT LIU2 LIU3 LIU4 CPRI2 LIU5 CPRI1 LIU6 CPRI0 LIU7
1 2 3 4
ETH_RS232
OFF
ON
2FE
CPRI0_TX CPRI0_RX
Ela
8 E1/T1 GPS
OFF ON
Page 23
Chapter2 Hardware Introduction Section1 Section2 Section3 Section4 BBU Hardware RRU Hardware BTS3801C Hardware Antenna and Feeder Subsystem
Page 24
RRU Overview
RRU3801C Dimension with the housing Weight 20W565mm(H)390mm(W)165mm(D) 40W610mm(H)380mm(W)200mm(D) 20WPower amplifier:18KG 40WPower amplifier:20KG 220V AC Power -48V DC Allowed voltage range AC150V AC300V AC/47Hz63Hz Allowed voltage range -40V DC-60V DC 210W
Power Consumption
240W
Sector Carrier
Page 25
RRU3801C
High speed serial interface module
Feedback channel
RNC
BBU3806
Rx1 Rx2
LNA LNA
Duplexer
DAC
PA
Tx1 Rx1
Page 26
RRU3801C Panel
Maintenance Panel
TST_ANT TST_CPRI ALM TX_ACT/ VSWR CPRI_E RUN TST_RSLT CPRI_W ETH/RS232 OFF ON
ANT_TX/RXA
1 2 3 4
Bottom Panel
PWR
Distributed Board
CPRI_E
LOCAT _ID
ANT_RXB
CPRI_W
RST
DIP Switchused to indicate the slot Number of RRU3801C, not used yet
Page 27
RRU3801C Indicators
Name Color Status Flashing slowly at 0.5Hz RUN Green Flashing fast at1Hz On Off Off ALM Red Meaning The RRU is working normally Software of the board is loading Checkout status of the version or BBU is faulty There is no power input or the BBU is faulty Theres no alarmexclude VSWR warning
On
Green is On Green flashing slowly at 0.5Hz Red and Green Red is On Red flashing slowly at 1Hz HUAWEI TECHNOLOGIES CO., LTD.
TX_A CT/VS WR
RRU3801C Indicators
Name Color Status Green is on Red is on TST_RSLT Red and Green Green flashes slowly at 0.5Hz Off Off CPRI_W Green On Flashing slowly at 0.5Hz Off CPRI_E Green On Test result is normal Test result is abnormal Being tested Un-tested status West port works normally or isnt used Meaning
Flashing slowly at The signal transmitted from west port loss 0.5Hz Page 29 HUAWEI TECHNOLOGIES CO., LTD. All rights reserved
Chapter2 Hardware Introduction Section1 Section2 Section3 Section4 BBU Hardware RRU Hardware BTS3801C Hardware Antenna and Feeder Subsystem
Page 30
BTS3801C Dimension Weight Power and Power Consumption 20W Power amplifier 40W Power amplifier Sector Carrier 610mm(H)380mm(W)390mm(D) 35kg 220V AC 220V AC 12 310W 340W
Page 31
Chapter2 Hardware Introduction Section1 Section2 Section3 Section4 BBU Hardware RRU Hardware BTS3801C Hardware Antenna and Feeder Subsystem
Page 32
Page 33
Page 34
Networking
BBUs and RNC can form multiple networking modes such as star, chain, tree,
cascading levels is less than 5 The BBUs in the ring topology require additional transmission equipment.
Page 35
Networking
BBUs and RRUs can form multiple networking modes such as star, chain, tree,
When using the 1.25 G optical module, cascading levels is less than 4
When using the 2.5 G optical module, cascading levels is less than 8
Page 36
Typical Configuration11
Applied to wide areas and indoor circumstances
Page 37
Typical Configuration21
Applied to long stretched areas
Page 38
Typical Configuration31
Applied to cities or other high capacity areas
Page 39
Thank You
www.huawei.com