Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Technologies Co.Ltd.
In this slide, well mainly introduce the hardware system structure,
application scenarios, basic functions of modules and networking and configuration of the DBS3800
Page 2
Application Scenarios of DBS3800 Hardware Structure of DBS3800 Functions of Different Modules Networking and Configuration Examples
Page 3
References
Page 4
Chapter1 General Description Chapter2 Hardware Introduction Chapter3 Networking and Configuration
Page 5
DBS3800 Overview
DBS3800 is a distributed NodeB of Huawei
Technologies Co.Ltd.
DBS3800 system consists of:
Antenna
BBU3806 RRU3801C
RNC
RRU3801C
TMA RF jumper
Power cable
BBU3806
+24V/-48V DC
RF jumper
Grounding cable
Power cable
Page 6
BBU3806
BBU3806C
RRU3801C
BTS3801C
Page 7
DBS3800 Installation
Traditional outdoor macro NodeB
Difficult to transport and move Need large space to locate Require long feeder
DBS3800 Distributed NodeB
RRU
small dimensioning design RRU can be installed near antenna The numbers of BBU and RRU can be configured according to different requirements
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 8
BBU
DBS3800 Deployment
Application scenario 1
Page 9
DBS3800 Deployment
Application scenario 2
Page 10
DBS3800 Deployment
Application scenario 3:
Launch a new 3G indoor site, there is an equipment room but the space is limited and load-bearing capacity is week
Page 11
DBS3800 Deployment
Application scenario 4
Launching a new 3G outdoor site, the operator has no equipment room or fiber resources, or it is very hard to route optical fibers
Page 12
DBS3800 Characteristics
supports circuit domain (CS) and packet (PS) domain services supports positioning services supports softer handover, soft handover and hard handover Supports transmit diversity mode and receive diversity mode Supports high-speed downlink packet access (HSDPA) technology
HSDPA allows the traffic at up to 14.4 Mbps for a single cell HDSPA enables a single cell to support 15 OVSF codes
Supports RRU cascading
The maximum distance between two RRUs is 40km The distance from the first one to the last one should be within 100km When using the 1.25 G optical module, cascading levels is less than 4 When using the 2.5 G optical module, cascading levels is less than 8
Page 13
Chapter1 General Description Chapter2 Hardware Introduction Chapter3 Networking and Configuration
Page 14
Section2 RRU Hardware Section3 Section4 BTS3801C Hardware Antenna and Feeder Subsystem
Page 15
BBU Overview
BBU3806 appearance
Index Dimension BBU3806 42mm(H)436mm(W)300mm(D)
BBU3806Cappearance
BBU3806C 610mm(H)380mm(W)200mm(D) (with
the
housing )
Weight Power and Power Consumption CE Numbers Cells 3kg -48V DC +24V DC 60W 60W 15kg 220V AC -48V DC 120W 100W
128CE(UL)/256CE(DL)(V17) 3
128CE(UL)/256CE(DL)(V17) 3
Page 16
Page 17
BBU3806 Panel
BITS GPS CPRI CPRI RUN ALM ACT FECPRI
LIU LIULIULIU LIULIULIULIU
EXT_ALM
BBU-RRU interface
Indicator
BBU-RNC interface
Page 18
Page 19
CPRI
CPRI Common Public Radio Interface
Page 20
BBU3806 Indicators
Name RUN Color green Status Meaning Flashing slowly at 0.5 Hz The BBU is working normally Flashing fast at 1Hz On Off ALM ACT LIU0 LIU7 red green green Off On On Off Off On Flashing CPRI0 green CPRI2 Off On Flashing The BBU is loading Checkout status of the version or BBU is faulty There is no power input or the BBU is faulty Theres no alarm exclude VSWR warning Theres alarm exclude VSWR warning The BBU is active The BBU doesnt work or it is standby or secondary The link isnt used or theres no alarm Near end alarm Far end alarm The port works normally or is closed The power of the signal received from the near end is not enough LOS alarm
Page 21
Meaning Active BBU3806 default value Standby BBU3806 Secondary BBU3806 Tertiary BBU3806 Meaning
Page 22
BBU3806C Panel
Maintenance Panel
RST M
Bottom Panel
RS & EXT_ALM PWR
Distributed Board
CPRI _TX CPRI _RX
RUN LIU
ACT LIU LIU LIU CPRI LIU CPRI LIU CPRI LIU
ETH_RS
OFF
ON
FE
OPT E /T GND
Ela
GPS
E /T
OFF
ON
Page 23
Section2 RRU Hardware Section3 Section4 BTS3801C Hardware Antenna and Feeder Subsystem
Page 24
RRU Overview
RRU3801C Dimension with the housing Weight 20W 565mm(H)390mm(W)165mm(D) 40W 610mm(H)380mm(W)200mm(D) 20WPower amplifier:18KG 40WPower amplifier:20KG 220V AC Power -48V DC 20WPower Power Consumption amplifier 40WPower amplifier Sector Carrier 12 Allowed voltage range AC150V AC 300V AC/47Hz 63Hz Allowed voltage range -40V DC 60V DC 210W 240W
Page 25
RRU C Feedback channel High speed serial interface module Transm it signal processor MTRX R eceive signal processor
ADC ADC
DAC
PA Dupl ex er
RNC
BBU
T x R x
R x R x
LN A LN A
R x A&F subsystem
Page 26
RRU3801C Panel
Maintenance Panel TST_ANT
TST_CPRI ALM TX_ACT/ VSW R CPRI_E RUN TST_RSLT CPRI_W ETH/RS OFF ON
Bottom Panel
PWR
Distributed Board
CPRI_E
ANT_TX/RXA
LOCAT _ID
ANT_RXB
CPRI_W
RST
DIP Switch used to indicate the slot Number of RRU3801C, not used yet
Page 27
RRU3801C Indicators
Name RUN Color Green Status Meaning Flashing slowly at 0.5Hz The RRU is working normally Flashing fast at1Hz On Off ALM Red Off On TX_ACT/ Red and VSWR Green Green is On Software of the board is loading Checkout status of the version or BBU is faulty There is no power input or the BBU is faulty Theres no alarm exclude VSWR warning Theres alarm exclude VSWR warning Power amplifier is working theres no VSWR alarm
Green flashing slowly at Power amplifier isnt working board is running 0.5Hz Red is On Power amplifier is working theres VSWR alarming on ANT_TX/RXA port
Red flashing slowly at Power amplifier is turned off and theres VSWR alarming 1Hz before it is turned off HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 28
RRU3801C Indicators
Name TST_RSLT Color Red and Green Status Green is on Red is on Test result is normal Test result is abnormal Meaning
Green flashes slowly Being tested at 0.5Hz Off CPRI_W Green Off On Un-tested status West port works normally or isnt used The power of the receiving signal on west port is too weak
Flashing slowly at The signal transmitted from west port loss 0.5Hz CPRI_E Green Off On East port works normally or isnt used The power of the receiving signal on east port is too weak
Flashing slowly at The signal transmitted from west port loss 0.5Hz HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 29
Section2 RRU Hardware Section3 Section4 BTS3801C Hardware Antenna and Feeder Subsystem
Page 30
BTS3801C Dimension Weight Power and Power Consumption 20W Power amplifier 40W Power amplifier Sector Carrier 610mm(H)380mm(W)390mm(D) 35kg 220V AC 220V AC 12 310W 340W
Page 31
Section2 RRU Hardware Section3 Section4 BTS3801C Hardware Antenna and Feeder Subsystem
Page 32
Page 33
Chapter1 General Description Chapter2 Hardware Introduction Chapter3 Networking and Configuration
Page 34
Networking
BBUs and RNC can form multiple networking modes such as star, chain, tree,
cascading levels is less than 5 The BBUs in the ring topology require additional transmission equipment.
Page 35
Networking
BBUs and RRUs can form multiple networking modes such as star, chain, tree,
When using the 1.25 G optical module, cascading levels is less than 4 When using the 2.5 G optical module, cascading levels is less than 8
Page 36
Typical Configuration11
Applied to wide areas and indoor circumstances
Page 37
Typical Configuration21
Applied to long stretched areas
Page 38
Typical Configuration31
Applied to cities or other high capacity areas
Page 39
Thank You
www.huawei.com