Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Security Level:
Drive Test
www.huawei.com
Huawei Confidential
Content
Introduction
Preparation
Scenario Means Example
Overview
DT is a method to collect
Huawei Confidential
Page 3
Huawei Confidential
Page 4
Level distribution
Call quality distribution Exceptional Event Capture Air interface signaling display
Huawei Confidential
Page 5
Typical configuration
Test Mobile
Attention:
Check whether the GPS is in NEMA mode or in NEMA 4800 mode. Check whether the GPS is in analog mode or normal mode
Huawei Confidential
Page 6
Connected ratio
Connected ratio = total connected times/attempted calls *100% Call drop rate = call drop times/total connected times *100% Coverage rate = ( -94dBm test road kilometers)/total test road kilometers*100% According to bit error rate, 8 classes, from 0 to 7. The calculation of voice quality depends on actual conditions. Voice quality = [Rxqual (class 0)% + Rxqual (class 1)% + Rxqual (class 2)%]*1 + [Rxqual (class 3)% + Rxqual (class 4)%]*0.8 +[ Rxqual (class 5)% + Rxqual (class 6)%]*0.5 + Rxqual (class 7)%*0.2
Coverage rate
Voice quality
Call drop ratio per kilometer = ( -94dBm test road kilometers)/total call drop times
Huawei Confidential Page 7
Preparation
Equipment Connect the devices and test to make sure the system operation well. Check the power of test mobile and charge it Prepare the charger for GPS and PC Map Electrical map is better Update your map all the time Engineer parameter Make sure the engineer data is precise and comprehensive as possible as you can Adjust the format to input the test software Make sure the geographic display of distribution of sites Setup Confirm test number Confirm talk time and break time Discuss with customer or base on your requirement Path Communication with customer Based on test requirement
Huawei Confidential
Page 8
Target
Key point
Suggestion
Select roads and areas as much as you can. Cover the coverage area of three cells of each sites
Huawei Confidential
Page 9
Target
Coverage and quality of current network are not worse than that of the original one
Key point
signal level and speech quality of each site Handover zone between two sites
Suggestion
Huawei Confidential
Page 10
Target
Key point
connectivity and handover is normal Signal level and interference band is normal
Suggestion
Single site test adopt round trip and cycle trip Check the project implement correct Make a call to check the speech problem
Huawei Confidential
Page 11
call drop/handover failure/access failure and so on Step1check signal level and quality
Step2: check signaling Predict the reason and plan how to verify. You should consider each possibility
Huawei Confidential Page 12
Means
Interference
Co-channel
Force handover Lock or shut down TRX Lock BCCH and forbid handover
External interference
spectrum analyzer
Directional Antenna
Handover zone
Round trip along the linear path between two cell Lock the kit onto the BCCH frequency and test in idle mode along the direction of main lobe
Coverage area
Inverse connection
Huawei Confidential
Page 14
Thank you
www.huawei.com