Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
UME 303
Credit 3 - 1L-2T-2T[CADLAB]
Introduction
Continuous thin
D Long break line.
Straight with zigzag.
•Hidden outlines.
E Dashed thick.
•Hidden edges.
TYPES OF LINES:- General applications-
F •Hidden outlines.
Dashed thin.
•Hidden edges.
•Center lines.
G Chain line •Lines of symmetry.
•Line of trajectories.
•Indication of lines or
surfaces to which special
J Thick chain line requirement applies.
TYPES OF LINES:-
General applications-
Lines Pencil
1. Aligned System
2. Unidirectional
System
Aligned System Unidirectional
System
Chain Dimensioning - Chains of single
dimensions should be used only where the
possible accumulation of tolerances does
not impinge on the functional requirements
of the part.
Superimposed running
•The following indications are used with dimensions to show applicable shape
identification and to improve drawing interpretation. The
diameter and square symbols may be omitted where the shape is clearly
indicated. The applicable indication (symbol) shall precede the value for
dimension