0 valutazioniIl 0% ha trovato utile questo documento (0 voti)
60 visualizzazioni25 pagine
This document provides instructions for integrating a BTS with an IP network. It includes steps to check the BTS software version, load new software if needed, activate the software, configure the BTS IP address and settings, configure routing and port IP settings, and reset the BTS. It also describes using ping tools to test connectivity from the laptop to both the router and BSC.
This document provides instructions for integrating a BTS with an IP network. It includes steps to check the BTS software version, load new software if needed, activate the software, configure the BTS IP address and settings, configure routing and port IP settings, and reset the BTS. It also describes using ping tools to test connectivity from the laptop to both the router and BSC.
This document provides instructions for integrating a BTS with an IP network. It includes steps to check the BTS software version, load new software if needed, activate the software, configure the BTS IP address and settings, configure routing and port IP settings, and reset the BTS. It also describes using ping tools to test connectivity from the laptop to both the router and BSC.
Setting IP Laptop Setting IP BTS Get Site Management Right Cek BTS Software Cek BTS Software • Klik Kanan di GTMU, pilih Board Information Cek BTS Software • Cek apakah Software GTMU sudah R014 atau belum? Load BTS Software Load BTS Software • Klik Browse untuk memilih software BTS Load BTS Software • Pilih “gtmudown.pck” Load BTS Software • Setting Version BTS sesuai dengan software BTS-nya (V100R014C00SP23), pilih “GTMU_MAIN”, Lalu Klik Start, tunggu sampai 100% Aktivasi BTS Software • Pilih Software Activation, masukan Version Softwarenya (V100R014C00SP23), pilih “GTMU_MAIN”, lalu klik “OK” Konfigurasi IP BTS Konfigurasi IP BTS • Klik “OK” Config BTS, BSC and VLAN • Klik Static IP Status ke “enable”, Rubah Com Type ke “Port IP”, setting BTS IP Address, dan BSC IP Address sesuai Planning IP, Rubah VLAN Flag ke “enable”, Setting VLAN ID sesuai planning, lalu “OK” Config BTS, BSC and VLAN Config Route • Pilih Config Route, Rubah Slot Number ke “6”, Setting Destination IP Address, Destination Mask Address, dan Next Hop Address, klik “OK”, tunggu sampai “Success” Config Port IP • Pilih “Config Port IP”, rubah slot number ke “6”, Setting FE0 IP Address dan FE0 IP Mask Address, lalu klik “OK”, tunggu sampai success Reset BTS Reset BTS • Langsung Klik “OK”, tunggu sampai site reset success, kemudian BTS akan restart, lihat indikasi lampu LED di GTMU. Ping Tools Setting IP Laptop Setting VLAN dan Destination ke arah Router • Setting Vlan ID dan Destination IP lalu klik “SEND” Setting VLAN dan Destination ke arah BSC • Setting Vlan ID dan Destination IP lalu klik “SEND” END