Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2014
Review the grips shown. Match each single line text justification point location with its description.
a. TC (Top Center)
b. MR (Middle Right)
c. BR (Bottom Right)
d. BC (Bottom Center)
e. MC (Middle Center)
You need to create a 1-unit square column that lines up with the two walls as shown.
Which is the most efficient technique to draw the column?
a. Draw construction lines and then trim as needed.
b. Set the snap to 1 and turn on Snap mode, then draw the lines using snap points.
c. Draw the lines over the top of the walls and then move the lines to the right location.
d. Turn on Object Snap and Object Snap Tracking from the status bar to draw the lines.
Radius
Diameter
2 Point
a.
b.
c.
d.
e.
f.
Ellipse
Rectangle
Circle
Polygon
Arc
Spline
Open the drawing file: Office.dwg and perform the following steps.
1. Zoom into the area labeled J.
2. Rotate the chair labeled A.
3. Use the Insert Object Snap of the chair as the base point for the rotation.
4. Rotate the front of the chair so it is parallel to the front of the desk.
What is the distance from the corner of the chair labeled C to the corner of the desk labeled D?
Scale 1
What is the distance from the front quadrant of the table labeled A to the corner of the column
labeled B?
A layout represents the dimensional size of a sheet of paper. You specify a logical name and paper size,
and insert your border and title block into it. When plotting a layout, you base the plot on the selected
size of paper.
What Plot Scale is typically used to plot the A1_Elev layout?
a. 1:40
b. 1:10
c. 1:96
d. 1:1
e. Scale to Fit
When using the JOIN command, you can combine similar objects into one object. Which
example is valid to join two objects together?
a. Closed rectangular Polyline and Line
b. Two non-collinear Lines
c. Two non-connected coplanar Splines
d. Arc and Line
Column Height
Column Width
Stretch
Flip Arrow
Move Text Only
Reset Text Position
Center Vertically
Stretch Vertex
Add Vertex
Remove Vertex
Convert to Arc
Convert to Line
Stretch
Lengthen Landing
Add Leader
Add Vertex
Remove Vertex
AutoCAD objects have multifunctional grips. You select an object and then hover over a grip to
view and access the multifunctional grip menu. Match the object with its available
multifunctional grips.
a. Dimension
b. Line
c. Mtext
d. Multileader
e. Polyline
f. Spline
You are creating a concrete pad for a 15-square unit shed at a specific angle using the Polar Tracking tool.
What is the current setting for the polar angle?
a. 6.5
b. 45
c. 15
d. 22.5