Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
DBS3800 Data
Configuration
DBS3800V100R007
www.huawei.com
Page 2
References
WRAN CME User Guide
DBS3800 Initial Configuration
Guide
Page 3
Page 4
Page 5
Planned Radio
data
Wizards of the
task focused
NodeB
Templates
CME
CME
Script is downloaded
and activated
RNS
RNS
RAN
RAN
RAN Initial Data Configuration
Page 6
Planned Radio
data
Wizards of the
task focused
Upload
NodeB
Templates
Script is downloaded
and activated
RNS
RNS
RAN
RAN
Adding/deleting/modifying a NodeB
Adding/deleting/modifying a cell
CME
CME
Page 7
Configuring
Physical
Equipment
Configuring
Local cell
Configuring
Transport
Page 8
Page 9
Physical
Equipment
Create NodeB
Add HBBU
Add MRRU
Chain/Ring
Add NPMU for
HBBU
Add MRRU
Add TMA
Add RET
End
HUAWEI TECHNOLOGIES CO., LTD.
Page 10
Page 11
Adding an HBBU
Note
You can add only one HBBU to a
NodeB
Page 12
Note
Chain
Ring
Star
Note
For the data configuration of a distributed NodeB, each MRRU is
considered as a subrack. The subrack number of an MRRU must be
unique within the distributed NodeB system
HUAWEI TECHNOLOGIES CO., LTD.
Page 13
Antenna
Adding a TMA
Adding RET
Adding a RET
Bracket
Jumper
TMA
Jumper
Feeder
Jumper
NodeB
Cabinet
Page 14
Page 15
Page 16
NCP
CCP
PCH FP
FACH FP
NBAP
RACH FP
Radio
Network
Layer
Transport
Network
Layer
User plane
Control Plane
DCH FP
Iub Interface
protocol
CCP
Transport Network
User Plane
Transport Network
Control Plane
Transport Network
User Plane
ALCAP
A
SAAL UNI
B
SAAL UNI
AAL2 PATH
ATM
Physical Layer
Page 17
Control
Plane
NodeB
ALCAP
NCP
CCP 1~n
RNC
User
Plane
NodeB
AAL2Path
Adjnode
Page 18
RNC
Transport
Configuration
Create NodeB
Procedure of Transport
Configuration
Add HBBU
Add ALCAP
Add NCP/CCP/
IPoA Device
End
End
Add Fractional
ATM
Page 19
Physical ports(DBS3800)
Board type
Port number
Work mode
IMA,UNI,
Fractional ATM,
IMA,UNI,
Fractional ATM
HBBU
E1/T1 port No.2~3
IMA, UNI,
Timeslot cross
(connect with lower level NodeB)
IMA,UNI
Page 20
Page 21
Configuration
Add an IMA Group
IMA group
PHY
Original
ATM cell stream
ATM
from ATM layer
PHY
IMA group
Physical I ink #0
PHY
Physical I ink #1
PHY
Physical I ink #2
PHY
PHY
Page 22
IMA Frame 1
...
ATM
m-1
...
ATM ATM
...
ICP2
...
m-1
ICP2 ATM
ATM
ATM
...
ICP1 ATM
m-1
...
ATM ATM ICP2
ATM
...
...
F
IMA Frame 0
ATM
ICP0 ATM
Filler cell
ATM
1
F
ICP0
Page 23
Link 0
...
Time
Link1
Link2
Page 24
Page 25
Page 26
Page 27
Page 28
Page 29
Page 30
Page 31
Page 32
Page 33
Transport
Network
Layer
CCP
CCP
Transport Network
User Plane
UDP
IP
IP
Physical Layer
Page 34
TFCI2 FP
CPCH FP
Transport Network
User Plane
SCTP
USCH FP
HSDSCH FP
NCP
PCH FP
NBAP
RACH FP
DCH FP
Radio
Network
Layer
FACH FP
User Plane
Control Plane
Configure the
PPP
Configure the
PPPoE
Configure the MP
Configure the
Ethernet IP
Configure
the IP Route
Configure
the QoS
NodeB
(optional)
Configure
the NBAP
IP Route
Configure
the IP
OMRoute
Configure
the IP path
End
Page 35
NodeB
RNC
IP network
IP hybrid transmission
HUAWEI TECHNOLOGIES CO., LTD.
Page 36
If the gateway type of the route is Ethernet, the next hop address and
the gateway IP address must be in the same network segment
If the NodeB and RNC are in layer 2 networking
The IP addresses of the FE ports on the NodeB and RNC should
be in the same subnet
If the NodeB and RNC are in layer 3 networking
The next hop address is the IP address of the router that
connects to the NodeB or the IP address of the port on a layer 3
switch.
The destination address of packets has the corresponding route in the
routing table.
The corresponding link layer address can be found only when the
router specifies the next hop IP address (gateway).
Configure just one route to the same destination address.
HUAWEI TECHNOLOGIES CO., LTD.
Page 37
Page 38
Page 39
Page 40
Page 41
Page 42
Add
A Site
Add
A Local
Cell
Add
A Sector
Page 43
Page 44
Page 45
Page 46
NMPT Ethernet
Port IP address
Subnet 4
RNC BAM IP
IPoA local IP
SNTP Server
Subnet 1
Subnet 3
Subnet 2
Subnet 5
RNC
M2000
DBS3800
LMT1
LMT 2
Page 47
BTS3812E
NMPT ETH IP
(A)
(B)
Configure IPoA
local IP: IP1
IP0
Lower level
Node B
IP1
Configure IPoA
local IP: IP6
IP: IP4
Local DBS3800
IP5
(B) Configure
networking PVC
IP2
IP3
IP6
The route to
LMT(IP4)
gateway:IP5
IPoA peer
IP: IP2
RNC
IPoA peer
IP:IP5
IP4
LMT
Page 48
Page 49
Thank You
www.huawei.com