Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1
The shape of clay particle
is usually
1
1.Angular
2.Flaky*
3.Tubular
4.Rounded
2
Principle involved in the
relationship between
submerged unit weight and
saturated weight of a soil is
based on
2
1. Equilibrium of
floating bodies
2. Archimedes
principle*
3. Stokes Law
4. Darcys law
Cohesion in soil ..
3
1. Decreases active pressure and
increases passive resistance*
2. decreases both active pressure
and passive resistance
3. increases the active pressure
and decreases the passive
resistance
4. increases both active pressure
and passive resistance
4
The possible location of shear centre of the
channel section, shown below, is
4
1.P*
2.Q
3.R
4.S
5
The action of negative skin
friction on the pile is to
5
1. maintain the working load on the
pile.
2.reduce the allowable load on the
pile.
3.increase the ultimate load on the
pile.
4.reduce the settlement of the pile.
6
The dimension for kinematic
viscosity is
6
1. (L2/T)*
2.(ML/T)
3.(L/T2)
4.(L/MT)
7
A given cohesionless soil has emax=
0.85 and emin= 0.50. In the field, the
soil is compacted to a mass density of
1800 kg/m3at a water content of 8%.
Take the mass density of water as 1000
kg/m3and Gsas 2.7. The relative
density (in %) of the soil is
7
1.60.25
2.56.43
3.62.87
4.65.71
8
A conventional flow duration
curve is a plot between
8
1.Duration of flooding and ground level
elevation
2.Duration of water supply in a city and
proportion of area receiving supply exceeding
this duration
3.Flow and percentage time flow is exceeded
4.Flow rate and duration of time taken to
empty a reservoir at that flow rate
9
For a saturated cohesive soil, a
triaxial test yields the angle of
internal friction () as zero. The
conducted test is
9
1.Consolidated Drained (CD) test
2.Consolidated Undrained (CU) test
3.Unconsolidated Undrained (UU)
test*
4.Unconfined Compression (UC) test
10
The potable water is prepared
from turbid surface water by
adopting the following treatment
sequence
10
1.Turbid surface water Disinfection Flocculation
Sedimentation Filtration Coagulation Storage &
Supply
2.Turbid surface water Coagulation Flocculation
Sedimentation Filtration Disinfection Storage &
Supply*
3.Turbid surface water Filtration Sedimentation
Disinfection Flocculation Coagulation Storage &
Supply
4.Turbid surface water Sedimentation Flocculation
Coagulation Disinfection Filtration Storage & Supply
11
In reservoirs with an uncontrolled
spillway, the peak of the plotted
outflow hydrograph
11
1.lies on the recession limb of the plotted
inflow hydrograph
2.is higher than the peak of the plotted inflow
hydrograph
3.lies outside the plotted inflow hydrograph
4.lies on the peak of the inflow hydrograph
12*
Accurate determination of
water content, is made by
12
1.calcium carbide method
2.sand bath method
3.alcohol method
4.oven-drying method*
13
The coefficient of
compressibility of soil, is the
ratio of
13
1.strain to stress*
2.stress to strain
3.rate of loading to that of
settlement
4.stress to settlement
14 FM*
A piezometer opening
in pipes measures
14
1.static pressure*
2.velocity head
3.total pressure
4.negative static pressure
15
Reynold number is the
ratio of initial force and
15
1.viscosity*
2.elasticity
3.gravitational force
4.surface tension
16*
In pipe lines, a surge tank
is provided
16
1. to provide additional water head
2.to relieve the pressure due to water
hammer*
3.to remove the frictional loss in pipe
4.to overflow the pipe line when
suddenly closed
17
The continuity equation
17
1.relates the momentum per unit volume
between two points on a stream line
2.expresses the relationship between work
and energy
3.relates mass rate of flow along a stream
line*
4.requires that Newton's second law of motion
be satisfied at every point in fluid
18*
Cavitation is caused by
18
1.High pressure
2.Low pressure*
3.High velocity
4.Low velocity
19*
From a nozzle exposed to
atmosphere, the liquid jet
traverses
19
1.a circular path
2.a straight line
3.a parabolic path*
4.an elliptical path
20*
On an inclined plane,
centre of pressure is
located
20
1.anywhere.
2.below the centroid*
3.above the centroid
4.at the centroid
21*
If velocities of fluid particles vary
from point to point in magnitude
and direction, as well as from
instant to instant, the flow is said
to be
21
1.laminar
2.uniform flow
3.turbulent flow*
4.non-uniform flow
22
Shear
stress
proportional to
is
directly
22
1.the
2.the
3.the
4.the
shear strain*
velocity
viscosity
density
23
The best side slope for most
economical trapezoidal section, is
23
1.30
2.45
3.60*
4.90
24 SUR
The station which is selected
close to the main triangulation
station, to avoid intervening
obstruction, is not known as
24
1.eccentric station
2.satellite station
3.pivot station*
4.false station
25 HYDRO
The standard height of a
standard rain gauge, is
25
1.10cm
2.20cm
3.30cm*
4.40cm
26
Precipitation caused by lifting
of an air mass due to the
pressure difference, is called
26
1.orographic precipitation
2.cyclonic precipitation*
3.convective precipitation
4.frontal precipitation
27
The run off a drainage
basin is
27
1. Precipitation - ground water accretion +
initial recharge
2. Initial recharge + ground water accretion +
precipitation
3.Precipitation + ground water accretion +
initial recharge
4.Precipitation - ground water accretion initial recharge*
28
The quantity of water
retained by the sub-soil
against gravity, is known
28
1.specific yield
2.porosity
3.yield
4.specific retention*
29
Isohytes are the imaginary
lines joining the points of
equal
29
1.pressure
2.humidity
3.height
4.rainfall*
30*
The average mean velocity of a
stream having depth h, may be
obtained by taking the average of
the readings of a current meter at
a depth of
30
1.0.1
2.0.2
3.0.3
4.0.4
h
h
h
h
and
and
and
and
0.9
0.8
0.7
0.6
h
h*
h
h.
31
Hydrograph is a graphical
representation of
31
1.ground water flow
2.surface run off
3.discharge flowing in the river*
4.rain fall
32
The earthen embankments
constructed parallel to the
river banks at some suitable
distance for flood control, are
known as
32
1.levees
2.dikes
3.both dikes and levees*
4.river walls
33*
Phytometer
method
generally
used
for
measurement of
is
the
33
1.evaporation
2.interception
3.transpiration*
4.evapotranspiration
34
1.W.C. area
2.Room area
3.Verandah area
4.Courtyard area*
35
The damp proof course
(D.P.C.) is measured in
35
1.Cub.m
2.Metres
3.None of these
4.Sq m*
36 TE*
For the movement of vehicles
at an intersection of two
roads,
without
any
interference, the type of
grade separator generally
preferred to, is
36
1.delta
2.trumpet
3.diamond interchange
4.clover leaf*
37
The weaving length of
roadway is the distance
37
1.equal to total width of adjoining
radial roads
2.between the channelizing islands*
3.equal to half circumference
4.equal to diameter of rotary.
38
On concrete roads, the camber
generally provided, is
38
1.1
2.1
3.1
4.1
in
in
in
in
36
30
48
60
to
to
to
to
1
1
1
1
in
in
in
in
48
48
60
72*
39
While
calculating
the
sight
distances, the drivers eye above
road surface, is assumed
39
1.90 cm
2.110 cm*
3.100 cm
4.120 cm
40*
Minimum permissible speed on
high speed roads, is decided on
the basis of
40
1.30
2.15
3.20
4.40
percentile
percentile
percentile
percentile
cumulative
cumulative
cumulative
cumulative
frequency
frequency*
frequency
frequency.
41
In an ideal transition curve, the
radius of curvature
41
1.is inversely proportional to the radius
of main curve*
2.is directly proportional to the radius of
main curve
3.at any point is directly proportional to
its distance from the point of
commencement
4.is constant
42
In
India
the
modes
of
transportation, in the order of
their importance, are
42
1.air transport, shipping, roads, railways
2.shipping, roads, railways, air transport
3.roads, railways, air transport, shipping
4.railways, roads, shipping, air
transport*
43*
The shape of a vertical curve, is
43
1.spiral
2.elliptical
3.parabolic*
4.circular
44
The first stage of deciding the
alignment of a hill road, is
44
1.detailed survey
2.trace-out
3.preliminary survey.
4.reconnaissance*
45 IRR*
When a canal is carried over a
natural drainage, the structure
provided, is known as
45
1.syphon
2.syphon-aqueduct.
3.aqueduct*
4.super passage
46*
SI unit for the surface tension, is
46
1.kg/m2
2.kg/m
3.kg/m3
4.N/m*
47
100 kN/m2pressure is equal to
47
1.1
2.1
3.1
4.1
atm
bar*
mm Hg
m bar