Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
10
System Tree
BTS
Base Transceiver Station
Host Unit
Convert From RF to Optical Signals
Remote
Convert From Optical to RF Signals
DAS
Distributed Antenna System
FlexWave Prism
Hardware Overview
Host Unit
Remote Unit
System board
Fan Tray DCV Power board Digital/Analog Radio Transceiver (DART) Boards
Alwadi Communications, 2013 4
Power Connection
The host has a modular DC to DC power supply located on the lower left side of the chassis. The host is powered by 20Vdc to 60Vdc power (nominal 24Vdc 48Vdc).
Computer Connection
In the default configuration, the Craft port has a DHCP server that assigns an IP address to computer that is connected. You should therefore have your network interface configured for DHCP, or configured with static IP address in the same subnet, where the default is 192.168.0.1/24.
Optical Connections
Improper handling can damage fiber optic cables. Do not bend fiber optic more sharply than the minimum recommended bend radius specified by the cable manufacturer.
The receivers specification is -9 to -27dBm. Based on typical fiber runs, theres usually only a few dB of loss, so the 15dB LC attenuator ships with each Host to put the receive level in the optimum receive range.
Alwadi Communications, 2013
The composite forward path RF signal level at the host must be between -25 and +5dBm. Do not connect the forward path cable until the composite forward path RF signal level is measured and amount of external attenuation required is determined.
1 to 4 Bands
10
SeRF Module
11
Mounting Hook
12
Door Alarm
AC Power Switch
Cover Latches Cable Guides SeRF Assembly Power Supplies under shield DC Power Switches
13
Craft Port
Status LED
Fiber
A/C Power
Band 2 Antenna (TX0/RX0) Band 4 Antenna (RX1) Band 2 Antenna (RX1) Band 3 Antenna (TX0/RX0) Band 3 Antenna (RX1)
1/26/2014
14 14
Welcome Page
15
16
17
18
19
20
21
Remote Summary
22
23
24
25
26
27
28
29
System Inventory
30