Sei sulla pagina 1di 26

MAGNUM

MCS-CONNECT

WWW.MCSCONTROLS.COM

MCS-CONNECT General Information

Windows based (95 thru 7)

Software written in Java


Grid size dynamic and updated in place Updated typically every 2 to 3 seconds Status, Trending/Graphs, Schedules Transmit / Receive Configurator about 60 seconds

MCS-CONNECT General Information


RS232 connection @ 19,200 baud Local Ethernet @ 100 Mbps Built in Gateway on each MAGNUM Transmit Software (Both .hex & .cfg) Expanded Graphing

Edit Date / Time Information

MCS-CONNECT OPENING SCREEN

Setup Windows & Modem Timers

Local Serial/Ethernet

Remote/Dialup & IP

SETUP COMMUNICATIONS

Local & Remote Com Ports

Modem Commands

S8=4

Timing Functions

Buffer Sizes

Communications Speeds

Phone Number Selection


Use Scroll Bar to Find Site

Drop down list of site names will appear. Use scroll bar to locate correct name or type name. When name is found click on it.

Phone Directory
After Selecting Dialup & Site Select Remote/Connect to Dial System


Site By MCS Address

Local or Remote
Get Authorized

Configurator Name

Model Name

Install Date Unit Serial #

Software Version # Config Date

Hardware Serial #

Manufacturer

Config Version

Authorization

Select Authorization Type 4 digit Auth # (0 thru 9) and Press ENTER on PC

Overall Status

Relay Outputs Analog Outputs

Notification

Control Status

Sensor Inputs Select Info

Relay Output Status


Value / Manual Status Last on / off Updated top of min Run Today /Yesterday Cycles Today /Yesterday

Relay Output Name

Scroll to Right & Get Total Run Hrs & Total Cycles

Relay

Output Status

Click on Name to highlight line Every Other Line Color Alternates

Drop Down Relay Output Auto, Manual, Lockout

Sensor Input Status


Current Value Manual/Auto Status Offset Value Sensor Type Last on/off or Min/Max

Sensor input Name

Sensor

Input Status

Set CHIL OUT Manual

Drop Down to Put Sensor in AUTO or MANUAL

Put

Sensor in Manual

Select Sensor Name

Put in Sensor Manual Value

Sensor
Sensor input Name

Input Status
Sensor Manual Status Sensor Offset & Type Run/Cycles or Min/Max Today

Sensor input Value


Unit status

Control Status

Circuit Status Temp, Superht Status

LLS/EXV status
Select Status, Alarms, SetPoints, Reset/Clear, Schedule & Service

Alarms

Last 100 Alarms

Select from tabs

Setpoints
Target Ctl Zone
Liquid Inj. On

EXV Set Points

Time ROC EXV

Setpoints

Capacity Ctl

Slide Capacity Ctl

Load Pulse Ctrl

Condenser Ctrl

Setpoints

Condenser Ctrl

Compressor Ctrl

Amp Ctrl

Low Suct PSI Ctrl

Setpoints

High Disc Psi Ctrl

High Disc Tmp Ctrl

Comp Safety Ctrl

Freeze & EXV Ctrl

Setpoints

Target

Enter New Value Target Adjusted with Reset Value Set Point Range

Graph

Graph Setup

Relay Outputs Selected

Analog Outputs Selected Sample Interval

Sensor Inputs Selected Grid Control

Hands

On Time

Access MCS-Connect Program Check Communications Settings Review Remote Phone List Local Connection to a Demo Unit

Potrebbero piacerti anche