Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
CRSBG 2012/06
1.Quantity of Supply()
Quantity of Supply() No.() 1 2 Span() 15.3m 18.3m Unit( each() each() Quantity() 3 5
3
4 5 6
24.4m
30.5m 36.6m Tools
each()
each() each() set
7
4 3 3
2.Description of member()
3.Description of Tools()
0.751m 6m
and landing side of the gap where the the bridge will be
erected. the rock roller is 0.75--1m off the bearings and layout in the direction of bridge launching. Temporary
5. Nose beam: when pushing the panels, firstly utilize the nose beam to stable the pushing process. usually a nose beam is assemblied out of a single collum and a single layer.
21 21 nose beam= bridge spans/2+1, cardinal bridge span, to have stability, use temporay
supporting frame
when the steel panel being pushing forward, there is a problem to make the bridge cantilever to the right position to the roller on the opposite site,hence a launching link is displaced to assure the right level and hight. 2)1 23 max. nose beams for the luaching link is 4, add links to 2,3 section if one is not enough. 3
6. bridge
assembling
stick to the worshop drawings, utilize chord tothe male and famale end
deck panel can be fixed before the truss beam is pushed, and fix the rest of the beam anchors.
7.pullpush and beam placement 1 to avoid bridge truss and span movement during the erection, make sure that the whole process can be controlled by break 2 use counter weight at the rear of the bridge 3 make becessary adjustment during the pulling and push process. 4 when instal the bridge beam, please make sure that nose beam and counter weight are removed. 5 use rocl roller to break when dismantling front end luanching link beam. 6 before displace the bridge truss, make sure all the bolts are sufficiently tightened 7 use jack to the rock roller, and place packings with the same hieght under each beam,2 use jack to lower the packing height and the bridge truss. repeat the process until all the panel being correcly installed. 8 when jacking the bridge truss, make the both ends proceed simultaneously 9 for safety, please displace one end after another.