Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
POWER
Photovoltaic Devices Photovoltaic effect recognized In 1839 followed by the first photovoltaic cell in 1883. Converts energy from the sun directly into electricity Used to power or recharge portable devices and for residential commercial use.
Generate electricity indirectly from the sun. Most commonly used Solar Power Tower, Parabolic Trough.
Used in large electric power production and for residential commercial use.
- Solar Panels are made up of a collection of solar cells that are then bonded to a sheet of glass. It converts sunlight into electricity which can be used immediately or stored in a battery. - Solar Cell is made of semiconductors, like silicon, that has special material properties that allow the sun light that strikes a cell to be absorbed in the material.
Charge controller
- Also known as charge regulator, monitors the battery's charge state. - Protect the battery from discharging, below its lowest acceptable voltage, to prevent damage by over discharge. - Protects against wrong connection of the battery and reverse voltage to the panel. - Stores the power generated by the solar modules during the day to be used during the night. - The type of battery used is Deep Cycle (Lead Acid) Maintenance Free type. - This battery is designed to be fully charged and discharged over and over again without causing damage.
Batteries
DC-AC Inverter
- DC-AC inverters are used to convert Direct Current (DC) from the battery into Alternating Current (AC) to run AC appliances. - Types of inverters available are Stand-alone inverters, Synchronous inverter and multi-function inverter
Stand-alone Inverter
Synchronous Inverter
Multi-function Inverter
Heliostat ~ Mirrors which reflects the suns energy to the correct Central Receiver ~ Receives spot on the tower. concentrated solar radiation and transform it to thermal power. 3 2 Molten Salt ~ Stores the sun's heat and release it in a controlled manner for steady steam turbine power generation.
Condenser ~ Condense exhaust steam from the steam turbine Turbine ~ Receives steam and channels it back to steam from steam generator that generator. turns the turbine blades to generate electricity.
Storage Tanks ~ Stores fluid, one at high temperature and one at low temperature.
~ Parabolic Trough ~
Collector ~ Structure of collector must : - Supports the mirrors and receivers, maintaining them in optical alignment - Withstands external forces(winds). - Allows the collector to rotate, so the mirrors and receiver can track the sun.
2 1 Mirrors ~ Usually coated with silver or polished aluminum. Reflects the suns energy to the receiver. 3
PARABOLIC TROUGH
Collector Interconnect ~ Connects the receivers on two adjacent collectors and allows them to track independently. 5 4
Steel tube ~Surrounded by a glass envelope to Drive ~ Positions the reduce convection heat collector to track the losses. Functions as a sun during the day. It receiver that can can be either a standard Fluid ~ Normally oil, absorbs sunlight, accept optical input motor and gear box configuration or can use increases temperature from any direction. a hydraulic drive System. and heats steam in turbine.
P h o t o v o l t a i c
G E N E R A T I O N
P R O C E S S
Converts energy from the sun into electricity. It monitors the condition of the battery state of charge and protects the battery from being over-charged.
The solar cells will convert sunlight directly into electricity (DC). The electricity from the solar cells is stored in the battery for immediate or later .
The role of the charge controller is to regulate the voltage and current from the solar cells before it is stored in the battery.
The charge controller will also protect the battery from discharging below its lowest acceptable voltage.
Where required, an inverter is used to change the Direct Current (DC) to Alternating Current (AC) to power most AC appliances.
Parabolic Trough
1. Greatly reduced pollution. 2. Greatly reduced contribution to global warming. 3. Infinite energy resource. 4. Reduced maintenance costs. 5. Falling production costs. 6. Low running costs. 7. Local application.
1. It is available most abundantly in areas with a high number of sunshine hours. 2. It is not directly available at night or under cloud cover. 3. DC power must be converted to AC power before it can be used. 4. Initial installation cost may be too expensive. 5. Solar panels require large land/roof areas to be effective.
With the threat of global warming, and the gradual depletion of petroleum supplies,
Why we don't use more solar energy? 1) The energy intensity of solar energy is relatively low. 2) The technology is expensive. Solar Thermal Vs Photovoltaic. Solar Thermal has an efficiency of 70% whereas PV 12%. Solar Thermal requires much less space than PV. Solar Thermal are 5 times cheaper than PV. Difficult to add thermal walls and other passive solar collectors to an existing home which gives an advantage to PV. Solar thermal space heating system will sit idly by during the long summer months while a solar PV system will provide usable electricity all year. Differences between Solar panels and Solar Modules : Technically, there is a difference, but even within the solar industry there is no clear cut answer. For all practical purposes, a solar panel is the same as a solar module.
Solar power is a good alternative energy source. It does not hurt the environment and it is a renewable energy source. Can be used to power houses and their electronic appliances, such as flashlights, electric motors and even refrigerators. It can also be used to heat water and cool buildings. Two ways to capture the suns energy, by Photovoltaic devices and Solar Thermal Electric Power Plant. Learned how solar energy can be used to make electricity and power everyday appliances. Also learned about structures of Photovoltaic Panels, Solar Thermal and how it works.
TH NK YOU