Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
- in detail
reflectors
IR Detectors
IR Source
Main connections
Installation
Cable
- 3-way 1mm2 to 2.5mm2. - 4-way can be used for dual mA output
Supply
- 10V- 32V @ 180mA (constant current)
Power
- 2-6W, extra power is dissipated as additional heat into the optics
Mounting
- Set orientation if mounted externally, or hosing may occur
Orientation
Operation
Start-up
- Nimbus takes less than 10 seconds to start detecting gas from power-up. Single green flash indicates normal operation.
Status LED
- The operating state and a wide range of faults can be determined using the LED - Green - Ok, Red - Gas, Orange - Fault
Modbus communications
Exd Comms connector fitted as standard
- Connects to PC or I.S. communicator, e.g. MTL611B - Software for PC and MTL available now - WindowsCE platforms will be supported
Wizards
Available with PC & MTL software Guides the user
- The user is lead through the zero and calibration process with a series of screens - Inhibit functions are automatically applied allowing oneman-operation without panel inhibits
Supplied as Standard
Weather proof cover
- Static dissipative plastic to meet the new ATEXT requirements
Communications port
- A flameproof optical communications port for connection to the I.S. cable. This is either M20 or 1/2 NPT to match the cable entry.
Accessories
Flow cover
- For calibration or gas testing
Approvals
Full UL flameproof approval
- Nimbus meets UL1203 Class 1, Div 1, Groups B,C,D - Cirrus meets UL2279 Class 1, Zones 1 & 2
Future Developments
Gas cell calibration WindowsCE support for rugged palm-tops and