Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The complete OSHA 600 based PowerPoint Presentation is available for subscribers to EH&S Manager Online.
4/3/2013
Introduction
This module is based on 29 CFR 1910 Subpart S and covers electrical work requirements designed to minimize potential accidents. The Occupational Safety and Health Administrations (OSHA) standards were developed to cover electrical system parts an employee would normally use or contact. In general, all equipment should be de-energized before an employee works on it. Otherwise, protective equipment and insulated tools are required.
3
4/3/2013
Objectives
At the end of the Electrical Work Practices module, you should be able to:
Identify hazardous locations Define proper safety related work practices Define safeguards for personal protection.
4/3/2013
Hazardous (classified) locations present a real threat to worker safety. They are areas where a potential for explosion and fire exist due to the presence of flammable:
4/3/2013
It presents a description of and the requirements for working in hazardous (classified) locations. This section covers the topics listed on the left. 29 CFR 1910.307 is based on the National Electrical Code (NEC), NFPA 70.
4/3/2013
Causes
4/3/2013
Causes
It is also possible that a hazardous location may occur when volatile solvents or fluids, used in a normal maintenance routine, vaporize to form an explosive atmosphere.
Each room, section, or area shall be considered individually when determining hazardous classification.
8
4/3/2013
Precaution
Despite the hazards of a location, every precaution must be taken to guard against ignition of the atmosphere. Certainly no open flames are permitted in these locations. Electric equipment capable of igniting flammable materials or gases shall not be used, unless measures are taken to prevent hazardous conditions from developing. There are many ways in which electrical equipment can act as a source of ignition in a hazardous location:
9
4/3/2013
Precaution
Switches, circuit breakers, motor starters, contactors, plugs, and receptacles all release arcs and sparks as contacts open and close during normal operation Lighting fixtures and motors are classified as "heat producing". They will become a source of ignition if their surface temperature exceeds the ignition temperature of the flammable material or gas An abnormality or failure in an electrical system, such as the failure of insulation, can release sparks, arcs, or heat.
10
4/3/2013
Wiring Installation
It is important to have an awareness of the problems that electrical equipment and wiring create when they are located in hazardous (classified) locations because several OSHA standards require the installation of electrical wiring and equipment in these locations. Most of these locations are defined in the "Hazardous (Classified) Locations" module available from the "Hazardous Materials" selection on the main menu.
4/3/2013
11
We're confident that you won't find a better one-source compliance solution at this low price. If you're not satisfied with your purchase, simply call us within 30 days for a full refund or credit.
4/3/2013
13
Just enter coupon code T272 in the coupon box when you pay online and you'll save $100! Join Now!