Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
ENGR 121
milling vise
xy table
digital readout (DRO) used to monitor the x, y and z positions due to turning the 3 crank handles
Make sure lock bolt for x-direction stage is unlocked an turned upward so that it wont interfere with table movement (or it could break off)
spindle handle for z-translation of spindle only (drill chuck only) (DOES NOT AFFECT DRO READOUT)
z-direction
Spindle Speed Control: Use the speeds recommended for each drilling operation
nut for locking down x stage of x-y table (be careful not to move the y-stage if this nut is downward (make sure its pointing upward), or you could break off the nut.
load drill bit or other tool into chuck and tighten with key
vise handle
3.
4.
Do not begin to fabricate your pump until you have carefully read the operating and safety instructions above and agree to operate the equipment in a responsible manner. You must sign the safety contract before beginning fabrication.
PVC cleaner
PVC glue
Download 2_PVC_cleaning.wmv video. Store video in the same directory as this presentation. Click on the picture to play video.
Download 2_PVCgluing.wmv video. Store video in the same directory as this presentation. Click on the picture to play video.
Hole Locations
tank inlet
tank drain
Hole Locations
Install tank drain a little lower than the other three upper fittings. The tank drain will set the water level in the tank. Since the other fittings are higher, you will be able to see the water from the pump and solenoid valves enter the tank.
Drill Holes
Q bit