Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Introduction
A jack is a device which lifts heavy
equipment.
Car jack is used to raise a car for
a flat tire.
12/31/12
Problem Statement
To design and develop electronic
car jack that operates on power obtained from car battery only if no external power source is required thus reducing human effort.
12/31/12
PROJECT MOTIVATION
Many people reported that changing
a car tire using existing(manually operated) jack is not a very pleasant experience.
Specially Women find it more
difficulties due to weaker skeleton and thus are at a greater risk of skeletal injuries.
Elderly people also find it very
Methodology
In the first phase of the project it was
decided that to calculate an average load of various car models. So that input load can be selected for jack design.
Design the jack completely and find
12/31/12
12/31/12
between central screw and every member to provide for extra strength.
To avoid tripping, a folding base can
12/31/12
CONT.
Most of jack accidents occur due to
tripping of jack on either of non supporting sides,this can be avoided by using a cross platform as shown above.
To facilitate efficient storage the
extra supporting bars can be made to swivelon a hinge such that the platform can be folded.
12/31/12
12/31/12
CONT.
The extended base removes tripping
problem.
Supporting arm adds stability
joints and arms can be folded , therefore jack becomes compact when not in use.
12/31/12
COMPARRATIVE STUDY
Simple design Easy to store Light weight Poor stability Poor strength cheap
Simple design
Complex design
Difficult to store Easy to store Little extra Increased weight weight Excellent stability Excellent stability Poor strength Moderate cost Greater strength Expensive
12/31/12
DESIGN EQUATIONS
12/31/12
DESIGN ASSEMBLY
12/31/12
12/31/12
12/31/12
MOTOR
Dc motor
suits our requirem ents,beca use it can be made to rotate into both directions by changing DC power
12/31/12
12/31/12
Contd.
Motor can be made to rotate the
screw of the jack by simply coupling the two shafts( screw shaft & motor shaft) through suitable gearing system.
12/31/12
Future Work
Fabricate and assemble the model
completely.
Testing of the model in our labs and
12/31/12
THANK YOU
12/31/12