Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Inner parts:
Specifications:
Max sewing speed: 5,500 rpm Normal sewing speed: 5000 rpm Stitch length: 5mm Presser foot lift: 10 mm The stitch length can be adjusted by turning knob
Specifications:
Max speed: 7000 rpm Stitch length: .5mm to 5.3mm Overedge width: 1.5mm to 6 mm Presser foot lift: 7mm Differential feed ratio: 1:.6 to 1:2.8 Equipped with HR device(needle/thread cooler) for cooling of heat generated due to needle movement allowing the thread to move smoothly and producing uniform stitches
Operations:
It contains two loopers and 2 needles That is 4 thread overlock machine An overlock stitch sews over the edge of one or two pieces of cloth for edging, hemming or seaming.
Proper Operations
Proper operations of the machine include the following: Threading Adjusting movement of differential feed dog (differential feed) Setting differential ratio to 1:1.1 1.2
Threading
Needle Thread
Pull thread until it reaches the front of the needles. And, cut off knots just before needle eye to re-thread.
Spreader Thread
Pull Thread until knot is out.
Looper Thread
Pull thread until the knot is out. Then, cut off the knot. Threading for sewing with UT or UT-A. For standard type, thread looper (5) through looper thread eyelet (left) (4) For less stretchable threads, thread looper (5) without threading looper eyelet (left) (4)
For easy threading, pull the lever (2) in the thread take-up eyelet holder (1).After threading, restore the holder (1) to the operating position with the lever(2)
Loosen the lock nut (3) For gather sewing, turn the adjuster (4) clockwise and the movement of the differential feed dog is increased. For stretch sewing, turn counterclockwise and the movement is decreased. Tighten the locknut (3) securely.
Remove the screws (3) of the differential feed bar connections(2). Fix the differential feed bar connections(2) to the tapped hole (4) with the removed screw(3).
Note
When the differential ratio is 1:2, the maximum stitch length of the main feed dog is 2.3mm. When the differential ratio is 1:5, the maximum stitch length of the feed dog is 3mm.
End Uses
By changing threading, you can obtain: 3 thread overlock 3 thread overlock with reinforcing tape 4 thread overlock 4 thread overlock with reinforcing tape Single needle double chain stitch 5 thread safety stitch (3 thread overlock+Single needle double chain stitch) 5 thread safety stich with reinforcing tape (3 thread overlock with reinforcing tape+Single needle double chain stitch) 6 thread safety stitch (4 thread overlock+Single needle double chain stitch) 6 thread safety stitch with reinforcing tape (4 thread overlock with reinforcing tape+Single needle double chain stitch)