Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
S =
Check for the Section Modulus , If
S ( Actual ) > S (
OR
Available
4. Designing the Additional plates . Calculate the area of the Flange plate. Area of flange Plate ( Ap ) = S (applied) - S (available) / Depth of Section Width of Additional plate (Wp) = (L / 35)
*From both width of additional plate we will select the maximum one . Thickness of Additional Plate ( Tp ) = Area of Additional plate / Width of Additional Plate
5. Calculate the Section Modulus due to Self Weight The total weight of the provided section is equal to the weight of available section. Total Weight of Section = Weight of available section + 2 ( width of flange plates ) * (thickness of flange plates) * (Density of Steel ) * ( 1 / ft ) * + Weigh of Rivet TO BE ASSUMED 6. Check for bending stress due to dead load and apply the check
S(
provided ) >
S ( Actual )
09CE37
31