Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
TECHNICAL SERVICES DEPT. copper alloys (Note) 8470 aluminium alloys (Note) 2700
insert dimensions for the required product shape in orange boxes, then read off the weight in the red boxes at right. Material: Note - Densities shown in green boxes are typical. Add specific density under "others" for different materials.
density:
sheet / plate flat bar coil round bar / wire square bar
Thickness (mm) Thickness (mm) Diameter (mm) 41 A/F (mm) A/F (mm)
Length (m) 1
kg: kg/m:
hex bar
A/F (mm)
oct bar
Thickness (mm) Leg 1 (mm) ID (mm) WT (mm) Side 2 (mm) WT (mm) Leg 2 (mm)
angle bar
OD (mm)
Length (m) 1 kg: Note: All results are approximate. Refer to second sheet for calculation fomulas. www.atlasmetals.com.au
Length (m) 0.02 Length (m) 1 Length (m) 1 Length (m) 1 Length (m) 1 Length (m) 1 Length (m) 1
0.21
0.21
0.22
0.07
0.13
revised 6/03/2006
PJM