Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
CP-1
Plus CP-1
II
SOURCE
TAPE
PRE
SYSTEM MUTE
EFFECT MUTE
POWER
SOURCE
MONITOR
TAPE
PANORAMA
1
WIDE
BANK
3
BANK switches between 12 factory Presets and 12 User registers where customized modes may be stored. PARAM selects the various adjustable parameters of the current mode. PARAM: UP and DOWN adjust the current parameter. EFFECT: UP and DOWN adjust the level or intensity of effects added by the CP-1. BALANCE: F and B adjust the levels between the front and the rear of the listener.
BINAURAL
The CONCERT HALL modes contain two effects: Ambience (Club and Hall) and Reverb (Cathedral). The Ambience effect generates the appropriate early reflections for stereo simulation of rectangular and fan-shaped halls in a variety of sizes. The Reverb effect emphasizes rich, smooth reverberant decay in small, medium or large spaces.
CONCERT HALLS
4
CLUB HALL
PARAM
6
CATHEDRAL
MUSIC SURROUND
7
FULL MUSIC
8
STEREO
MOVIE SURROUND
10
MONO
11
12
TV MATRIX
EFFECT
BALANCE
B L
VOLUME
The Surround modes are designed to make full use of additional loudspeakers at the center, sides and rear of the room. In MUSIC SURROUND, FULL allows unprocessed music to be played over all your speakers. MUSIC LOGIC is appropriate for any type of music and for stereo films which are not Dolby encoded. STEREO LOGIC envelopes you as though you were on stage with the musicians. The MOVIE SURROUND modes work with film sound tracks to recreate the theater experience. MONO LOGIC expands the music and effects on monaural films. TV MATRIX provides surround effects for TV viewing of monaural, stereo and stereo-synthesized programs. PRO LOGIC should be used during playback of any encoded films or music.
BALANCE: L and R adjust the left/right balance of all speakers: front, sides and rear. VOLUME: UP and DOWN adjust the level of all channels simultaneously. SYSTEM MUTE turns off all outputs and lights both SYSTEM and EFFECT MUTE LEDs. EFFECTS MUTE turns off any effects added by the CP-1. (Pushing EFFECT MUTE while in system- mute mode turns the effects alone back on.)
SYSTEM
EFFECT
MUTE
Note
To store a modified Preset program, press PARAM until the display reads: MEMORIZE PROGRAM, then press any of the 12 program keys to store all current settings in the corresponding User register. User registers automatically store changes as they are entered. The CP-1s User Bank can be cleared and reloaded with duplicates of the factory Preset programs at any time. Turn on the CP-1 while holding down PARAM. Continue to hold down PARAM for several seconds. This puts the unit into TEST mode. Push EFFECT MUTE to clear and reload the User Bank and to restore all initial settings of Volume, Balance, Contrast, Configuration, etc. Push PARAM again to begin normal operation.
OUTPUTS
R
Push Phantom/In if you have no center channel; leave it out if a center speaker is connected. Leaving this button out with no center channel will cause the Surround programs to malfunction.
Configuration
Press BANK and hold for five seconds. The display will read: LCD CONTRAST ADJ. The CP1 is now in Configuration mode.
Center Phantom Button IN Center Phantom Button IN
Use PARAM UP or DOWN to adjust display contrast. Push PARAM to select the Speaker Configuration menu. Push PARAM UP or DOWN until the configuration you have chosen and the description in the display match.
10
11
12
If you are using only one rear speaker, or a single amplifier channel for the rears, it may be hooked up to either the left or right rear output, as long as you use the correct Configuration number. Subwoofers are not shown in any of these configurations. Consult the subwoofer owner's manual or your dealer for proper placement of subwoofers.
Choose the diagram that most closely corresponds to your room and note its number.