Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
February 2009
Proudly bearing the name of the founder of the nation - the late Sheikh Zayed bin Sultan Al Nahyan - Zayed University was founded in 1998 to inspire, encourage, educate, and lead a powerful generation of students. Zayed University is a public urban non-profit institute of higher education founded in 1998 that is located in Abu Dhabi, United Arab Emirates. The non co-educational university caters to both national and international students with undergraduate and graduate programs. The new campus is being built on 75 hectares at New Khalifa City near Abu Dhabi International Airport. When complete, the new campus will have a built-up area of 200,000 m2 and provide educational facilities for 6000 students. Completion is expected in July 2011. Atlantis products are being used as part of the stormwater system. Over 6.1km of infiltration channels or soakaways have been installed beside roads and pathways, providing over 4 million litres of storage. The channel system is constructed of thousands of Atlantis Matrix / D-Raintank - Double Modules wrapped in geotextile, placed in the channel two modules wide. Water from the impervious surfaces is stored in the modules and gradually allowed to percolate into the surrounding soil. The infiltration channels are sized to make sure that it doesnt overflow in severe storm events and to ensure that all the water is dissipated effectively into the surrounding area. A concrete sump has been provided a regular intervals to ensure that sand and vegetation matter cannot enter the infiltration channel. The project is being developed by Mubadala Development Company, which is wholly owned by the Abu Dhabi government and the main contractor for the stormwater is Al Habtoor Specon Hastie International, a joint venture between Al Habtoor Engineering and Hastie Group Limited.
ESTABLISHED IN 1986
ESTABLISHED IN 1986
ESTABLISHED IN 1986
NOTES:
80mm NATURAL STONE PAVING INSIDE RECESSED COVER 600x600x130mm (CLEAR INTERNAL)
RECESSED MANHOLE COVER 600X600X130MM (CLEAR INTERNAL SIZE) OF STAINLESS STEEL OF GRADES 304 & 316 (TO BS 1449 PART-2) 80mm NATURAL STONE PAVING INSIDE
1. 2.
All dimensions are in millimeters unless specified otherwise. The grated slot inlet and its accessories are of RECYFIX STANDARD 100 by Hauraton or similar of Load Class 125KN. The grated slot inlet must have an intake cross section of 650cm/m length and must be galvanized. The Composite Channels system must meet the requirements of DIN EN 1433 or equivalent standards, and they must be suitable for loading capacity of CATEGORY B125, LOAD CLASS 125KN The Channel must have a width of 210mm and height of 192mm and is made up of PE-PP material or similar that satisfies the above noted standard.
3.
600
5.
600
A
STIFFENING RIB
6.
The channels must have a built-in-fall to direct flow to opposite direction of the surface pavement flow when necessary. The last channel section, which is adjacent to the catch-basin, must be provided with vertical outlet at the bottom of the channel with diameter of 150mm for discharging the flow from the channel to the catch basin.
7.
100
8.
In lengthy grated-slot channel-runs of more than 20m length, an inline trash-box with plastic bucket and galvanized iron grating cover, Class B125, should be installed. Channel runs must be connected to catch basins either via trash boxes or end-caps with horizontal uPVC outlet, including the necessary bends to vertically align the connection to the required invert level at the catch basin. The adjoining surface finishes shall be laid to finish permanently 3mm higher than the top edge of the channel. The surfaces to be bonded have to be sufficiently firm, dry, clean and free from oil and grease to ensure that bonding and curing is not adversely affected.
9.
10.
DETAIL 1
PLAN AT COVER LEVEL
SEE DETAIL 1
11.
SCALE 1:3
RECESSED MANHOLE COVER 600X600X130MM (CLEAR INTERNAL SIZE) OF STAINLESS STEEL OF GRADES 304 & 316 (TO BS 1449 PART-2) 80mm NATURAL STONE PAVING INSIDE RECESSED COVER
RECESSED MANHOLE COVER 600X600X130MM (CLEAR INTERNAL SIZE) OF STAINLESS STEEL OF GRADES 304 & 316 (TO BS 1449 PART-2) 80mm NATURAL STONE PAVING INSIDE RECESSED COVER
600
600
Nov-2008
FIRST ISSUE
150
800 MIN
200
STIFFENING RIB SUPPLIED WITH COVER 150 uPVC PIPE FROM GRATED SLOT or SLOT OPENING
150
STIFFENING RIB SUPPLIED WITH COVER 150 uPVC PIPE FROM GRATED SLOT or SLOT OPENING
VARIES
300 VC PIPE WATERPROFFING MEMBRANE ACCORDING TO QCS 2007 (SECTION 5, CLAUSE 14.3)
250
250
200
200
100
150
800
150
100
100
150
800
150
100
SECTION A-A
10
XX
SECTION B-B
TYPICAL CATCH BASIN WITH RECESSED TRAY COVER
SCALE: 1:10 @A1
ESTABLISHED IN 1986
HEAD OFFICE: 3/19-21 Gibbes Street, Chatswood, NSW 2067, Australia PHONE: + 612 9417 8344 FAX: + 612 9417 8311 AUSTRALIA WIDE PHONE NO.: 1300 38 28 38 EMAIL: info@atlantiscorp.com.au WEB: www.atlantiscorp.com.au Atlantis Water Management Victoria 30 Venture Drive, Sunshine, VIC 3020 Australia PHONE: 1300 38 28 38
Agent: