Sei sulla pagina 1di 8

Public Address Plan Symbol

Symbol

Component Name Audio Attenuator 5W

Function A line-level attenuator in the preamp or a power attenuator after the power amplifier uses electrical resistance to reduce the amplitude of the signal that reaches the speaker, reducing the volume of the output. A line-level attenuator has lower power handling, such as a 1/2-watt potentiometer or voltage divider and controls preamp level signals, whereas a power attenuator has higher power handling capability, such as 10 watts or more, and is used between the power amplifier and the speaker. A loudspeaker (or "speaker") is an electroacoustic transducer that produces sound in response to an electrical audio signal input. Non-electrical loudspeakers were developed as accessories to telephone systems, but electronic amplification by vacuum tube made loudspeakers more generally useful. The most common form of loudspeaker uses a paper cone supporting a voice coil

Audio Attenuator 30W

Audio Attenuator 75W

Audio Attenuator 120W

Ceiling Loudspeaker

Foreground Music Loudspeaker

Full Range Loudspeaker System

Horn Loudspeaker

electromagnet acting on a permanent magnet, but many other types exist

Wall Mounted Loudspeaker

Microphone Handheld

Microphone Emergency

A microphone (colloquially called a mic or mike; both is an acoustic-to-electrictransducer o r sensor that converts sound into an electrical signal

Microphone Desktop

Microphone Lapel

Microphone Wireless

Remote Paging Console 10-Zone

Remote Paging Console 20-Zone

Remote controls are used anytime a two-way radio base station is located away from the desk or office where communication originates. For example, a dispatch center for taxicabs may have an office downtown but have a base

Remote Paging Console 40-Zone

station on a distant mountain top.

Remote Paging Console 100-Zone

Power Supply Unit Compact

A power supply is a device that supplies electrical energy to one or more electric loads. The term is most commonly applied to devices that convert one form of electrical energy to another, though it may also refer to devices that convert another form of energy (e.g., mechanical, chemical, solar) to electrical energy. A subwoofer is a woofer driver used only for the lowest part of the audio spectrum: typically below 200 Hz for consumer systems, below 100 Hz for professional live sound and below 80 Hz in THX-approved systems. Because the intended range of frequencies is limited, subwoofer system design is usually simpler in many respects than for conventional loudspeakers, often consisting of a single driver enclosed in a suitable box or enclosure.

Subwoofer Unit

Fire Protection Plan Symbol

Symbol

Component Name Convention

Function Behind cutting plane Hidden Behind cutting plane Visible Beyond cutting plane Visible Beyond cutting plane Hidden

Any type Gas Extinguisher

Portable Free standing Water Extinguisher

Halon Gas Extinguisher

Portable Free standing Foam Extinguisher

A fire extinguisher or extinguisher, flame entinguisher is an active fire protection device used to extinguish or control small fires, often in emergency situations. It is not intended for use on an out-of-control fire, such as one which has reached the ceiling, endangers the user (i.e., no escape route, smoke, explosion hazard, etc.), or otherwise requires the expertise of a fire department

Carbon DiOxide Extinguisher

Dry Powder Extinguisher

Water Bucket

BC Dry Powder Extinguisher

Sand Bucket

ABC Dry Powder Extinguisher

Fire Blanket

Wall Mounted

Fixed to a wall

Ground Hydrant in Chamber Double

Pillar Hydrant Single

A hydrant is an outlet from a fluid main often consisting of an upright pipe with a valve attached from which fluid (e.g. water or fuel) can be tapped.

Pillar Hydrant Double

Ground Hydrant in Chamber Single

Hosereel

A Hose Reel is a cylindrical spindle made of either metal, fiberglass, or plastic and is used for storing a hose The fastest path to your safety

Escape Route

Escape Route, Final Exit

General Hazard Warning

Oxidizing Materials Risk Area

Flammable Materials Risk Area

Explosive Materials Risk Area

A location (1) in which ignitable concentrations of flammable gases or vapors can exist under normal operating conditions; (2) in which ignitable concentrations of such gases or vapors may exist frequently because of repair or maintenance operations or because of leakage; or (3) in which breakdown or faulty operation of equipment or processes might release ignitable concentrations of flammable gases or vapors and might also cause simultaneous failure of electrical equipment that could act as a source of ignition. A door is a movable structure used to open and close off an entrance, typically consisting of a panel that swings on hinges or that slides or rotates inside of a space.

Door Set, Hinged Leaf

Door set, Sliding/folding, End Hung

Smoke Vent on Plan

In firefighting, ventilation is an important part of structural firefighting tactics, and involves the expulsion of heat and smoke

Smoke Vent over on Plan

Roof Light Vent on Plan

Roof Light Vent over on Plan

Smoke Vent in Horizontal or Vertical Section

from fire building, permitting the firefighters more easily and safely find trapped individuals and attack the fire. If a large fire is not properly ventilated, not only will it be much harder to fight, but it could also build up enough poorly burned smoke to create a smoke explosion, or enough heat to create aflashover. Contrarily, poorly placed or timed ventilation may increase the fire's air supply, causing it to grow and spread rapidly.

Fan

A local exhaust fan can enhance infiltration or natural ventilation, thus increasing the ventilation air flow rate.

Potrebbero piacerti anche