Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Specifications
Watts Manifold Pressure Test Kits come pre-assembled to allow for easy pressure testing of manifold connections with either air or water. Copper Manifold Pressure Test Kits are fitted with O-ringed Brass Unions (MNPT/NPT).
Installation Parameters
ttach the pressure test kit to the manifold pair making certain A the rubber o-rings are properly seated before threading the unions together. sing the Schraeder valve for air or the water fill valves for liquid, U fill the system (air or water, but not both). lose the valve and fill. Pressure test the system with 50-100 psi C (3.5 - 6.9 bar) water or air for 24 hours. o help detect possible damage caused during the concrete pour, keep T the system under pressure. Note: I f the exterior temperatures are near or below freezing (32F (0.0C)) use air to pressure test. If a fluid must be used, use a 50-50 water/glycol solution. Failure to use glycol may result in frozen circuits. Do not test over 100 psi (6.9 bar), as this will damage the gauge on the test kit. Some minor pressure changes will occur due to the increase internal temperatures of the concrete as it begins the curing process. Fluctuations in air temperature may also cause a slight change in the test pressure. In most cases, a 10-15 psi (0.69 - 1.0 bar) drop in pressure over a twenty four hour period is not uncommon. For detailed information on the proper steps to conducting a pressure test, refer to Watts Heating PEX and Heating PEX-AL-PEX installation sheet.
QTY 1 kit
WT. (lbs) 3 4
CAUTION
This Engineering Sheet is not intended to provide full installation instructions and safety information. In order to avoid property damage or injury, please refer to the complete installation manual and product safety information provided with the product.
OT FOR
TA
BLE
Watts product specifications in U.S. customary units and metric are approximate and are provided for reference only. For precise measurements, please contact Watts Technical Service. Watts reserves the right to change or modify product design, construction, specifications, or materials without prior notice and without incurring any obligation to make such changes and modifications on Watts products previously or subsequently sold.
PO
Supply Manifold
Return Manifold
USA: No. Andover, MA Tel. (855) 699-2887 Fax: (978) 794-1848 radiant.watts.com Canada: Burlington, ONT. Tel. (905) 332-4090 Fax: (905) 332-7068 radiant.watts.com
ES-Pressure-Test-Kits 1142
2011 Watts