Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
then recombines into a single conductor, thereby enclosing a loop. It was originally used for measurement purposes, but can also be used in power supplies.
Schematic of a Wheatstone bridge The best-known bridge circuit, the Wheatstone bridge, was invented by Samuel Hunter Christie and popularized by Charles Wheatstone, and is used for measuring resistance. It is constructed from four resistors, one of which has an unknown value (Rx), one of which is variable (R2), and two of which are fixed and equal (R1 and R3), connected as the sides of a square. Two opposite corners of the square are connected to a source of electrical current, such as a battery. A galvanometer is connected across the other two opposite corners. The variable resistor is adjusted until the galvanometer reads zero. It is then known that the ratio between the variable resistor and its neighbour is equal to the ratio between the unknown resistor and its neighbour, and this enables the value of the unknown resistor to be calculated. The Wheatstone bridge has also been developed to measure impedance in AC circuits, resulting in designs such as the Wien bridge, the Maxwell bridge and the Heaviside bridge. All are based on the same principle, which is to compare the output of two potentiometers sharing a common source. In power supply design, a bridge circuit or bridge rectifier is an arrangement of diodes or similar devices used to rectify an electric current, i.e. to convert it from an unknown or alternating polarity to a direct current of known polarity. In some motor controllers, a H-bridge is used to control the direction the motor turns.
Maxwell bridge Phantom circuit - a use of balanced bridge circuits Wheatstone bridge Wien bridge oscillator Bridge T circuit
[edit] Gallery
Wheatstone bridge
Wien bridge
Maxwell bridge
H bridge
H bridge
Fontana bridge
Diode bridge
Diode bridge
Diode bridge
Kelvin bridge
Lattice bridge
Bridge T circuit
Bridge T circuit
Bridge T circuit
Bode network
Bridge circuits - Chapter 8 from an online book. Wien, Shering, Hay, Owen, Maxwell, and Resonance Bridges - With balance equations
Personal tools
Navigation Search
Special:Search
Go
Search
Interaction Toolbox
About Wikipedia Community portal Recent changes Contact Wikipedia Donate to Wikipedia Help
What links here Related changes Upload file Special pages Printable version Permanent link Cite this page
Languages
This page was last modified on 13 December 2009 at 18:25. Text is available under the Creative Commons Attribution-ShareAlike License; additional terms may apply. See Terms of Use for details. Wikipedia is a registered trademark of the Wikimedia Foundation, Inc., a non-profit organization. Contact us Privacy policy About Wikipedia Disclaimers