Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Seminar Report On
Submitted By
ARUN.T.S Reg.No:AMAIEEC021
2011-2012
Dept of ECE.
ii
Certificate
This is to certify that this seminar report entitled WIRELESS BATTERY CHARGER is being submitted by ARUN.T.S (Reg.No:AMAIEEC021) in partial fulfillment of the requirements for the award of degree of Bachelor of Technology in Electronics and Communication Engineering under the University of Calicut.
Seminar Guide
Mrs. Bindhu.P
Dept.of ECE
Dept of ECE.
iii
ACKNOWLEDGEMENT
The success accomplished in this seminar would not have been possible without the timely help and guidance rendered by many people to whom I feel obliged and grateful. I express my deepest sense of gratitude to the principal Dr.
M.R.VIKRAMAN for giving me an opportunity to study in this esteemed college. I am very much grateful to our head of the department Mrs. BINDHU.P, for her continuous encouragement to fulfill my seminar. I also thank our seminar coordinator Mrs. CHAITHANYA RAJ for instructions, guidance, information and timely help on how to complete the seminar I utilize this occasion to express my sincere gratitude to Mr. ANOOP.V our seminar guide for his valuable guidance, great thoughts which helped me in this seminar. . I say thanks to the teaching staffs and lab assistants of electronics and communication department for providing me a golden opportunity to do my seminar in Al-Ameen engineering college. Finally I express my everlasting thanks to all my friends whose valuable suggestions, criticism and encouragement that helped to make this seminar a great success. I also thank my parents for their prayer through which my seminar was successfully completed. Above all I thank god for his continuous blessing, without his proper help, I cannot complete this seminar successfully.
Dept of ECE.
iv
ABSTRACT
This report covers the basis and design of the wireless battery charger. The wireless charger will convert the RF/ microwave signal at 900 MHz frequency into a DC signal, and then store the power into an AAA battery. The project is divided into 3 parts: transmitter, antenna, and charging circuit. A complete discussion of the specifications of the battery charger is provided after data measurements. This report also includes component list, financial, data results, and other key information.
Dept of ECE.
TABLE OF CONTENTS
CHAPTER TOPIC PAGE NO.
ABSTRACT LIST OF TABLES LIST OF FIGUFES 1. 2. 3. INTRODUCTION DESIGN OVERVIEW ENGINEERING PROCEDURE 3.1 3.2 3.3 4. TRANSMITTER ANTENNA RECEIVER
iv vi vii 1 2 3 3 4 5 7 7 7 9 11 12 14 14 15 16 17 18 19
FINAL DESIGN 4.1 4.2 1P-SPICE SIMULATION THE FINAL DESIGN CIRCUIT
5. 6. 7. 8.
TESTING AND DATA SPECIFICATIONS PROBLEMS AND SOLUTIONS POSSIBLE IMPROVEMENTS 8.1 8.2 MULTIPLE RECTIFIERS HIGH GAIN PARABOLIC ANTENNA
LIST OF TABLES
Al Ameen College of Engineering Dept of ECE.
WIRELESS BATTERY CHARGER TABLE NO 3.1 5.1 6.1 12.1 12.2 12.3 12.4 NAME Specification of the Transmitter Voltage and Current versus Distance Charged Design Specifications HG909Y 9dBi Yagi Antenna Specification Diode Specifications I Diode Specifications II Parabolic Antennas Specifications PAGE NO 3 9 11 19 20 20 21
vi
LIST OF FIGURES
FIGURE NAME PAGE NO
Dept of ECE.
WIRELESS BATTERY CHARGER NO The overall wireless battery charger design Block Diagram of the Transmitter 900 MHz Video/Audio Transmitters 9dBi Gain Yagi Antenna Full Wave Rectifier Circuit Full Wave Rectifier with Capacitor and Resistor Simulation Result I (t: 0-5us) Simulation Result II (t: 4.9-5.0 us) Transmitter with the Yagi Antenna Final Design Circuit of the Charging Circuit Voltage versus Distance Chart Current versus Distance Chart Power versus Distance Chart Single Rectifier multiple Rectifiers Multiple Rectifiers with Multiple Spiral Antennas. HG909Y Vertical Gain Pattern. HG909Y Horizontal Gain Pattern Parabolic Antenna Gain Pattern
vii
2.1 3.1 3.2 3.3 3.4 3.5 4.1 4.2 4.3 4.4 5.1 5.2 5.3 8.1 8.2 8.3 12.1 12.2 12.3
2 3 3 5 6 7 8 8 9 9 10 11 11 15 15 15 20 20 23
Dept of ECE.