Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
10 kA
4.5 kA and 6 kA
RCBOs are a compact means of achieving operator and line protection in a single device. They are used whenever plant availability requirements are high. The RCBOs are themselves protected against overload by their own circuitbreaker element. There is no way that excessive load currents could result in unintentional overload. Each electrical circuit has its own RCBO assigned to it. The full fault current is therefore available to each circuit as leakage current. If a fault current occurs in a circuit, only the circuit concerned is de-energized, which contrasts sharply with what happens when there is group of MCBs located upstream of activated RCCBs. In the event of a fault, all fault-free circuits remain on voltage, making for a high degree of plant availability. The standard pin busbar is located to the rear, which makes it considerably easier to connect busbars and wires simultaneously. It is easy to check whether assembly has been carried out correctly. The extensive range of additional components available for the 5SY miniature circuit-breaker can be used.
Dimensional drawing
Dimensions in mm
1 N
I2_06001a
2 NT
Ordering data/Product overview
Range Rated fault current [MA] Pole Rated short-circuit capacity [kA] 4.5 6 10 4 4 4 4 4 MCB characteristic/RCCB type B Type AC1) C Type AC1) -1 -1 -0 -1 -6 B Type A2) -6 C Type A2) -7 -7 -7 Version Version KK KK KK KK KK 6 8 Rated current [A] 10 13 16 20 25 32 40
3 3
6 6 6
06 10 13 16 06 08 10 13 16 06 10 13 16 06 10 13 16 06 10 13 16
20 20 20 20
25 25 25 25
32 32 32 32
40 40 40 40
5SU1
5 1P+N 10kA
-6 B char. Type A
KK S tandard 16 A
16
RCBO
30mA
1) 2)
Type AC: AC-current-sensitive fault-current detection Type A: AC- and pulse-current-sensitive fault-current detection
w w w.siemens.de /bet a
The information provided in this brochure contains merely general descriptions or performance characteristics, which in case of actual use do not always apply as described or which may change as a result of further development of the products. An obligation to provide the respective characteristics shall only exist if expressly agreed in the terms of contract.
Siemens AG Automation and Drives Electrical Installation Technology P. O. Box 10 09 53 93009 Regensburg Germany
Siemens AG 2005 Subject to change without prior notice 03/05 Order No. E20001-A3190-P400-X-7600 Printed in Germany Planning and Scheduling Dept. 25601 10815596 MK.ET.01.WMBE.59.5.09 SB 09050.5