Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 42
Make: Model: Year:
LincoIn Aviator 2003-2005
FUNCTON COLOR LOCATON
Start: Dk.Green (+) gnition switch harness
gnition #1: Red/Lt.Green (+) gnition switch harness*
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Gray/Yellow (+) gnition switch harness
Brake Light: Lt.Green (+) Brake pedal switch
Tach Signal: N/A
Parking Lights: Brown (+) Headlight switch or CSM**
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: * Equipped with a transponder anti-theft system. See Note #144 **The Central Security
Module (CSM) is below the passenger side C pillar.
LincoIn Aviator 2003-2005
FUNCTON COLOR LOCATON
Constant +12 Volts: Yellow (+) gnition switch harness
OEM Alarm Disarm: Dk.Green/Purple (-) Drivers door harness or CSM**
Dome
Lights/Superv:
Black/Lt.Blue (+) Underdash light
OEM Horn: Yellow/Lt.Blue (-) Steering column harness
Power Lock: Pink/Yellow (-) Drivers door harness or CSM**
Power Unlock: Pink/Lt.Green (-) Drivers door harness or CSM**
Trunk Release: Purple/Yellow (+) Blue plug at CSM**
Alarm nput Wire: Black/Lt.Blue (+) Underdash light
NOTES: **The Central Security Module (CSM) is below the passenger side C pillar. See also
Note #201 negative trigger door locks.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 42
Make: Model: Year:
LincoIn BIackwood 2002
FUNCTON COLOR LOCATON
Start: RED/LT. BLUE GNTON SWTCH HARNESS **
gnition #1: D BLUE/GREEN GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW GNTON SWTCH HARNESS
gnition #3: RED/BLACK GNTON SWTCH HARNESS
Accessory: BLACK/LT. GREEN GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE/PNK AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Powertrain Control Module (PCM) Located On Passenger Side Of Engine
Compartment On Passenger Wheelwell. This Wire Can Also Be Found At the Firewall Harness
On the Driver's Side of Vehicle. ** This Vehicle s Equipped With Ford's PATS Anti-Theft System.
See nstallation Note #144 - Bypassing Transponder Theft Systems.
LincoIn BIackwood 2002
FUNCTON COLOR LOCATON
Constant +12 Volts: YELLOW (2), ORG/YEL
&
L GREEN/PURPLE (2) GN. SW. HARNESS
OEM Alarm Disarm: D GREEN/PURPLE (-) DRVER KCK PANEL
Dome
Lights/Superv:
BLACK/L BLUE (+) PASSENGER KCK PANEL
OEM Horn: D BLUE (-) STEERNG COLUMN HARNESS
Power Lock: PNK/YELLOW DRVER'S KCK PANEL **
Power Unlock: PNK/L GREEN DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/L BLUE (+) PASSENGER KCK PANEL
NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram,
With OEM Keyless See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 42
Make: Model: Year:
LincoIn ContinentaI 1983-1985
FUNCTON COLOR LOCATON
Start: '83 WHTE/PNK OR '84-85 RED/LGHT BLUE - GN. SW. HARN
gnition #1: RED/LGHT GREEN GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW 14 AWG GNTON SWTCH HARNESS **
gnition #3: GRAY/YELLOW-2WRES GNTON SWTCH HARNESS **
Accessory: BLACK/LGHT GREEN GNTON SWTCH HARNESS
Brake Light: LGHT GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: DARK GREEN/YELLOW AT COL *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Throttle Body njection Engine. ** See Note #127 - Ford gnition Switch Connection
Diagram.
LincoIn ContinentaI 1983-1985
FUNCTON COLOR LOCATON
Constant +12 Volts: YELLOW AND YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: DARK GREEN/PURPLE (-) N ETHER KCK PANEL
Dome
Lights/Superv:
BLACK/LGHT BLUE (+) AT PN SWTCH OR COURTESY LGHT
OEM Horn: DARK BLUE (+) STEERNG COLUMN HARNESS
Power Lock: PNK/LGHT GREEN DRVER'S KCK PANEL OR
Power Unlock: PNK/YELLOW BEHND GLOVE BOX ***
Trunk Release: PURPLE/YELLOW (+) AT RELEASE SWTCH
Alarm nput Wire: BLACK/LGHT BLUE (+) AT PN SWTCH OR COURTESY LGHT
NOTES: *** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram,
With OEM Keyless See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 42
Make: Model: Year:
LincoIn ContinentaI 1986-1990
FUNCTON COLOR LOCATON
Start: RED/LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/LGHT GREEN GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW GNTON SWTCH HARNESS
gnition #3: GRAY/YELLOW GNTON SWTCH HARNESS*
Accessory: BLACK/LGHT GREEN GNTON SWTCH HARNESS
Brake Light: LGHT GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: DARK GREEN/YELLOW AT COL, TEST CONNECTOR OR DSTRB.
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (LO) OR LGHT GREEN/BLACK (H) (+) LGHT SW.
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * See Note #127 Not all vehicles have 2 gry/yellow wires. f the vehicles has two gry/yel
wires, the second MUST be powered with a relay as per note 127.
LincoIn ContinentaI 1986-1990
FUNCTON COLOR LOCATON
Constant +12 Volts: YELLOW AND YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: DARK GREEN/PURPLE (-) N ETHER KCK PANEL
Dome
Lights/Superv:
BLACK/LGHT BLUE (+) AT PN SWTCH OR COURTESY LGHT
OEM Horn: YELLOW/LGHT GREEN (-) STEERNG COLUMN HARNESS
Power Lock: PNK/LGHT GREEN DRVER'S KCK PANEL **
Power Unlock: PNK/YELLOW OR BEHND GLOVE BOX **
Trunk Release: PURPLE/YELLOW (+) AT RELEASE SWTCH
Alarm nput Wire: BLACK/LGHT BLUE (+) AT PN SWTCH OR COURTESY LGHT
NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram,
With OEM Keyless See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 42
Make: Model: Year:
LincoIn ContinentaI 1991
FUNCTON COLOR LOCATON
Start: RED/LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/LGHT GREEN GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW 14 AWG GNTON SWTCH HARNESS *
gnition #3: GRAY/YELLOW-2WRES GNTON SWTCH HARNESS *
Accessory: BLACK/LGHT GREEN GNTON SWTCH HARNESS
Brake Light: LGHT GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: TAN/YELLOW AT COL OR GNTON MODULE
Parking Lights: BROWN (+) AT LGHT SWTCH OR AT FUSE BOX
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * See Note #127 - Ford gnition Switch Connection Diagram.
LincoIn ContinentaI 1991
FUNCTON COLOR LOCATON
Constant +12 Volts: 5 YELLOW GNTON SWTCH HARNESS
OEM Alarm Disarm: DARK GREEN/PURPLE (-) N ETHER KCK PANEL
Dome
Lights/Superv:
BLACK/LGHT BLUE (+) AT PN SWTCH OR COURTESY LGHT
OEM Horn: YELLOW/LGHT GREEN (-) STEERNG COLUMN HARNESS
Power Lock: PNK/YELLOW DRVER'S KCK PANEL **
Power Unlock: PNK/LGHT GREEN OR BEHND GLOVE BOX **
Trunk Release: PURPLE/YELLOW (+) AT RELEASE SWTCH
Alarm nput Wire: BLACK/LGHT BLUE (+) AT PN SWTCH OR COURTESY LGHT
NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram,
With OEM Keyless See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 42
Make: Model: Year:
LincoIn ContinentaI 1992-1994
FUNCTON COLOR LOCATON
Start: RED/LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/LGHT GREEN GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW 14 AWG GNTON SWTCH HARNESS *
gnition #3: GRAY/YELLOW-2WRES GNTON SWTCH HARNESS (BLOWER) *
Accessory: BLACK/LGHT GREEN GNTON SWTCH HARNESS
Brake Light: LGHT GREEN SWTCH ABOVE BRAKE PEDAL ON
BRACKET
Tach Signal: TAN/YELLOW OR
WHTE/PNK AT GNTON CONTROL
MODULE
Parking Lights: BROWN (+) HEADLGHT SWTCH OR DRVER KCK
PANEL
Headlights: RED/YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * See Note #127 - Ford gnition Switch Connection Diagram.
LincoIn ContinentaI 1992-1994
FUNCTON COLOR LOCATON
Constant +12 Volts: (5 TOTAL) 3 YELLOW & 2 YELLOW/WHTE - GNTON SWTCH
HARN
OEM Alarm Disarm: DARK GREEN/PURPLE (-) N ETHER KCK PANEL
Dome
Lights/Superv:
BLACK/LGHT BLUE (+) ANY PN SWTCH OR DRVER KCK PANEL
OEM Horn: YELLOW/LGHT GREEN
(-)
STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: PNK/YELLOW DRVER'S KCK PANEL **
Power Unlock: PNK/LGHT GREEN DRVER'S KCK PANEL **
Trunk Release: PURPLE/YELLOW (+) RELEASE SW. OR REAR BODY HARNESS
Alarm nput Wire: BLACK/LGHT BLUE (+) ANY PN SWTCH OR DRVER KCK PANEL
NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram,
With OEM Keyless See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 42
Make: Model: Year:
LincoIn ContinentaI 1995
FUNCTON COLOR LOCATON
Start: RED/LGHT BLUE GNTON SWTCH HARNESS
gnition #1: BROWN/PNK GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW #1 GNTON SWTCH HARNESS (ECM)
gnition #3: GRAY/YELLOW #2 GNTON SWTCH HARNESS (BLOWER) **
Accessory: BLACK/LGHT GREEN GNTON SWTCH HARNESS
Brake Light: LGHT GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: ORANGE/WHTE AT PN 2 ON GN CONTROL MODULE *
Parking Lights: TAN/WHT(+) AT LGHT CONTROL MODULE ***
Headlights: LGHT GREEN/BLACK
(+)
H BEAM, LO BEAM NOT RECOMMENDED
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * gnition Control Module Located On Driver Rear Of Engine Compartment On Fender
Apron. ** Use A Relay To Power Second Gray/Yellow Wire. See Note #127
LincoIn ContinentaI 1995
FUNCTON COLOR LOCATON
Constant +12 Volts: (4) BLACK/ORANGE GNTON SWTCH HARNESS
OEM Alarm Disarm: DK GREEN/PURPLE (-) SQUARE 84 PN CON. BEHND DRV DASH
Dome
Lights/Superv:
BLACK/LGHT BLUE (+) SQUARE 84 PN CONN. BEHND DR. DASH
OEM Horn: DARK BLUE(-) SQUARE 84 PN CONN. BEHND DR. DASH
Power Lock: PNK/YELLOW PASSENGER'S KCK PANEL ****
Power Unlock: PNK/LGHT GREEN PASSENGER'S KCK PANEL ****
Trunk Release: ORANGE/LT GRN (-) SQ. 84 PN CON.BEHND DR. DASH
Alarm nput Wire: BLACK/LGHT BLUE (+) SQUARE 84 PN CONN. BEHND DR. DASH
NOTES: ** Light Control Module Located Behind nstrument Cluster. *** See Note #203 reverse
polarity door lock diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 42
Make: Model: Year:
LincoIn ContinentaI 1996
FUNCTON COLOR LOCATON
Start: RED/LGHT BLUE GNTON SWTCH HARNESS
gnition #1: BROWN/PNK GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW GNTON SWTCH HARNESS (HEAT/AC) **
gnition #3: SECOND
GRAY/YELLOW
GNTON SWTCH HARNESS **
Accessory: BLACK/LGHT GREEN GNTON SWTCH HARNESS
Brake Light: LGHT GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED/YEL, PNK/WHTE, D BLUE/GREEN & RED/L BLUE *
Parking Lights: TAN/WHTE (+) AT LGHT CONTROL MODULE **
Headlights: LGHT GREEN/BLACK
(+)
AT H-BEAM RELAY
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Wire Colors Listed For Tach Signals Are At Coil Packs On Driver Front Of Engine.
Each Wire s A 2 Cylinder Signal. ** See Note #127 - Ford gnition Switch Connection Diagram.
LincoIn ContinentaI 1996
FUNCTON COLOR LOCATON
Constant +12 Volts: L GREEN/PURPLE (2) & WHTE/YELLOW (2) GNTON SW
HARNESS
OEM Alarm Disarm: DARK GREEN/PURPLE
(-)
N SQ.84 PN CONN.BEHND DRVER DASH
Dome
Lights/Superv:
BLACK/LGHT BLUE (+) N SQ.84 PN CONN.BEHND DRVER DASH
OEM Horn: DARK BLUE (-) STEERNG COLUMN HARNESS
Power Lock: PNK/YELLOW PASSENGER KCK PANEL ***
Power Unlock: PNK/LGHT GREEN PASSENGER KCK PANEL ***
Trunk Release: ORANGE/LGHT GREEN
(-)
SQ.84 PN CONN.BEHND DR. DASH
Alarm nput Wire: BLACK/LGHT BLUE (+) N SQ.84 PN CONN.BEHND DRVER DASH
NOTES: ** Light Control Module (LCM) Located Behind Driver Dash. TAN/WHTE (+) Only
Powers Front Parking Lights. Left Rear Light- WHTE (+), Right Rear Light - WHTE/RED (+) At
LCM. *** See Note #203 reverse polarity door lock diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 42
Mak
Model:
Year:
LincoIn ContinentaI 1997
FUNCTON COLOR LOCATON
Start: RED/L BLUE GNTON SWTCH HARNESS
gnition #1: BROWN/PNK GNTON SWTCH HARNESS
gnition #2: GRAY/YELLOW GNTON SWTCH HARNESS (HEAT/AC) **
gnition #3: SECOND
GRAY/YELLOW
GNTON SWTCH HARNESS **
Accessory: BLACK/L GREEN GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
D BLU/L GRN, RED/L
BLU
PNK/WHT & RED/YEL AT COL PACKS *
Parking Lights: TAN/WHTE (+) AT LCM (FRONT PARK LGHTS ONLY) ***
Headlights: BROWN (-) AT LGHTNG CONTROL MODULE **
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Each Wire Listed Above s A 2 Cylinder Signal. ** See Note #127 - Ford gnition
Switch Connection Diagram.
LincoIn ContinentaI 1997
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/YELLOW (2) & L GREEN/PURPLE (2) GN. SW. HARNESS
OEM Alarm Disarm: D GREEN/PURPLE (-) DRVER KCK PANEL
Dome
Lights/Superv:
BLACK/L BLUE (+) AT LGHTNG CONTROL MODULE (LCM) **
OEM Horn: D BLUE (-) STEERNG COLUMN HARNESS
Power Lock: PNK/YELLOW PASSENGER KCK PANEL ****
Power Unlock: PNK/L GREEN PASSENGER KCK PANEL ****
Trunk Release: BLACK/YELLOW (-) AT TRUNK RELEASE SWTCH
Alarm nput Wire: BLACK/L BLUE (+) AT LGHTNG CONTROL MODULE (LCM) **
NOTES: ** Lighting Control Module (LCM) Located Behind Driver Dash. *** TAN/WHTE (+) Wire
Powers Front Park Lights Only. WHTE (+) Wire At LCM Powers Left Rear Park Lights And
WHTE/RED (+) At LCM Powers Right Rear Park Lights. **** See Note #202 - Positive Pulse
Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 42
Make: Model: Year:
LincoIn ContinentaI 1998-2002
FUNCTON COLOR LOCATON
Start: Red/Lt.Blue (+) gnition switch harness
gnition #1: Brown/Pink (+) gnition switch harness*
gnition #2: Gray/Yellow (+) gnition switch harness
gnition #3: Gray/Yellow (+) gnition switch harness
Accessory: Black/Lt.Green (+) gnition switch harness
Brake Light: Lt.Green (+) At the LCM**
Tach Signal: White/Pink (AC) At the PCM***
Parking Lights: Orange/Black (+) At the LCM**
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: *This car is equipped with Fords PATS Anti-Theft system. Use a universal alarm bypass
module. See also Note #127 **The Lighting Control Module (LCM) is attached to the headlight
switch. ***The Powertrain Control Module (PCM) is located in the top of the firewall just off center
towards the passenger side. ****The drivers door module is located in the drivers door and is
attached to the door switches.
LincoIn ContinentaI 1998-2002
FUNCTON COLOR LOCATON
Constant +12 Volts: Black/Orange (+) gnition switch harness
OEM Alarm Disarm: Dk.Green/Purple (-) nside drivers door module****
Dome
Lights/Superv:
Black/Lt.Blue (+) At the LCM**
OEM Horn: Dk.Blue (-) At the LCM**
Power Lock: Pink/Yellow (+) nside the drivers door module****
Power Unlock: Pink/Green (+) nside the drivers door module****
Trunk Release: Orange/Lt.Green (-) At the LCM**
Alarm nput Wire: Black/Lt.Blue (+) At the LCM**
NOTES: **The Lighting Control Module (LCM) is attached to the headlight switch. ****The drivers
door module is located in the drivers door and is attached to the door switches.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 42
Make: Model: Year:
LincoIn LS 2000-2002
FUNCTON COLOR LOCATON
Start: GREY/BLACK GNTON SWTCH HARNESS *
gnition #1: GREEN/BLACK GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: PNK/YELLOW GNTON SWTCH HARNESS**
Accessory: PNK/WHTE OR
PNK/BRN
GNTON SWTCH HARNESS
Brake Light: ORANGE/YELLOW AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: BLUE/BLACK (+) AT SWTCH
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: * This vehicle is equipped with a transponder immobilizer system. See nstallation Note
#144 - Bypassing Transponder Theft Systems. ** See Note #127. gnition 3 must be powered
with a relay.
LincoIn LS 2000-2002
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: GRAY/ORANGE (-) AT MODULE
Dome
Lights/Superv:
BLACK/WHTE (-) UNDER DASH LGHT
OEM Horn:
Power Lock: BLACK/BLUE (-) N DRVER'S DOOR AT SWTCH **
Power Unlock: BLACK/WHTE (-) N DRVER'S DOOR AT SWTCH **
Trunk Release: WHTE (-) AT SWTCH UNDER DASH
Alarm nput Wire: BLACK/WHTE (-) UNDER DASH LGHT
NOTES: ** See nstallation Note #201 - Negative Pulse Door Lock Diagram. The Unlock
Requires Two Pulses. A Single Pulse Will Only Unlock The Driver's Door Only.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 42
LS 2003 -2006
KEY
T-
HARNES
S
MMOBLZER
FD KEY-
6
N/A
FORD'S SECURLOCK ANT-THEFT TRANSPONDER SYSTEM, Requires and
Extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER GRAY/BLACK (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 GREEN/BLACK (+) GNTON SWTCH HARNESS
GNTON 2 PNK/WHTE (+) GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
PNK/YELLOW (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) See NOTE *1
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK BLACK/BLUE (TYPE B)
@ DDM Module, 20 Pin Plug
Pin 16, See NOTE *2
POWER UNLOCK
BLACK/WHTE (TYPE B)
Requires Double Pulse
@ DDM Module, 20 Pin Plug
Pin 17, See NOTE *2
DOOR TRGGER BLACK/ BLUE (-)
@ FEM Module 20 Pin plug, Pin
12, See NOTE *3
DOMELGHT SUPERVSON TURNS ON with UNLOCK
TRUNK RELEASE WHTE (-)
@ FEM Module 26 Pin plug, Pin
4, See NOTE *3
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 42
MARK LT 2006
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
FORD'S SECURLOCK ANT-THEFT TRANSPONDER SYSTEM, Requires and Extra
gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT LGHT GREEN/PURPLE (+)
@ GNTON SWTCH
HARNESS
STARTER RED/LGHT BLUE (+)
@ GNTON SWTCH
HARNESS
STARTER 2 N/A
GNTON 1 DARK BLUE/LGHT GREEN (+)
@ GNTON SWTCH
HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/LGHT GREEN (+)
@ GNTON SWTCH
HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+)
@ HEADLGHT SWTCH or
BCM, BLUE Plug, Pin 6, See
NOTE *1
POWER LOCK PNK/YELLOW (TYPE B)
N DRVER KCK PANEL or
BCM, GREEN Plug, Pin 9, See
NOTE *1
POWER UNLOCK PNK/LGHT GREEN (TYPE B)
N DRVER KCK PANEL or
BCM, GREEN Plug, Pin 1, See
NOTE *1
DOOR TRGGER See NOTE *2
@ BCM, GREEN Plug, See
NOTE *1
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 42
TACH
Any wire that is NOT RED or
RED/LGHT GREEN
@ ANY GNTON COL or
FUEL NJECTOR
WAT TO START LGHT N/A
BRAKE LGHT GREEN (+) @ LCM Module, See NOTE *1
FACTORY ALARM DSARM LGHT BLUE/BLACK (-) @ LCM Module, See NOTE *1
ANT-THEFT
FORD'S SECURLOCK ANT-
THEFT TRANSPONDER
SYSTEM
TRANSPONDER @ GNTON
SWTCH TUMBLER
EXTRA NFORMATON
NOTE *1 the LCM (Lighting Control Module) is located to the RGHT of the STEERNG COLUMN.
NOTE *2 this vehicle uses a 5-wire TRUNK RELEASE SYSTEM, that will require an extra Relay Part
#775, to connect, . NOTE *3 the DRVERS DOOR Module is located below the mirror in the Drivers
door. NOTE *4 the TACH wire is located at the front of the motor, the coil is on the first spark plug on
the drivers side. NOTE *5 this vehicle has 2 Door trigger wires, when connecting to an ALARM
SYSTEM, use both DOOR TRGGER wires and DODE SOLATE, to connect,
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 42
ZEPHYR 2006
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
FORD'S SECURLOCK ANT-THEFT TRANSPONDER SYSTEM, Requires and Extra
gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT BROWN/RED (+)
@ GNTON SWTCH
HARNESS
STARTER BLUE/WHTE (+)
@ GNTON SWTCH
HARNESS
STARTER 2 N/A
GNTON 1 WHTE/ORANGE (+)
@ GNTON SWTCH
HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
PURPLE/GREEN (+)
@ GNTON SWTCH
HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY (-)
@ HEADLGHT SWTCH or
SJB, Connector D, Pin 5, See
NOTE *1
PARKNG LGHTS ( + ) GRAY/YELLOW (+)
N DRVERS KCK PANEL or
SJB, Connector E, Pin 30, See
NOTE *1
POWER LOCK GRAY/YELLOW (TYPE B)
N DRVER KCK PANEL or
SJB, Connector C, Pin 4, See
NOTE *1 and NOTE *2
POWER UNLOCK PURPLE/GRAY (TYPE B)
N DRVERS KCK PANEL or
SJB, Connector C, Pin 10, See
NOTE *1 and NOTE *2
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Lincoln - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 42
DOOR TRGGER
Use DOME LGHT
SUPERVSON wire
DOMELGHT SUPERVSON BLUE (+)
N DRVERS KCK PANEL or
SJB, Connector E, Pin 16, See
NOTE *1 and NOTE *3
TRUNK RELEASE BROWN (-)
@ TRUNK RELEASE SWTCH
or SJB, Connector D, Pin 27,
See NOTE *1
SLDNG POWER DOOR N/A
HORN BLUE/WHTE (-)
@ HORN SWTCH or SJB,
Connector B, Pin 6, See NOTE
*1
TACH NOT GRAY or WHTE/BLUE
@ Any FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE PURPLE/WHTE (+)
@ SWTCH above BRAKE
PEDAL or SJB, Connector A,
Pin 19, See NOTE *1
FACTORY ALARM DSARM PURPLE/BROWN (-)
N DRVERS KCK PANEL or
SJB, Connector C, Pin 5, See
NOTE *1 and NOTE *4
ANT-THEFT
FORD'S SECURLOCK ANT-
THEFT TRANSPONDER
SYSTEM
@ GNTON SWTCH
TUMBLER
EXTRA NFORMATON
NOTE *1 the SJB (Smart Junction Box) is part of the FUSE/RELAY BOX under the DRVERS SDE
of the DASH. NOTE *2 On Vehicles with MEMORY SEATS, the POWER LOCK and UNLOCK wires
are in the PASSENGER KCK PANEL or SJB (Smart Junction Box) and you will need to TEST these
wires while using the LOCK/UNLOCK Switch on the Passenger Door only. NOTE *3 the
DOMELGHT SUPERVSON wire BLUE (+) can also be located in the PASSENGER side "A" Pillar.
NOTE *4 Test this wire will turning the Key in the Drivers Door Key Cylinder.