Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Chassis SP20SO
Model LA20S51B
SERVICE
TFT-LCD TV
Manual
CONTENTS
1. Precautions 2. Product Specifications 3. Disassembly & Reassembly 4. Alignment & Adjustments 5. Troubleshooting 6. Exploded View & Parts List 7. Electrical Parts List 8. Block Diagram 9. Wiring Diagram 10. PCB Layout 11. Schematic Diagrams 12. Panel Description
2 Product Specifications
2-2-2 S-Video
Pin Separate
2-2-3 A/V
RCA Yellow CVBS Audio L RCA White GND Audio R RCA Red GND
2-2-4 D-SUB
Pin 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Separate Red Green Blue GND GND (DDC Return) GND-Red GND-Green GND-Blue No Connection GND-Sync / Self Test GND DDC Data H - Sync V - Sync DDC Clock
2-2
2 Product Specifications
IBM
640/75 Hz, 60Hz, 72Hz 640 x 480 800/75 Hz, 56Hz, 1024/60Hz 60Hz, 72Hz 1024 x 768 800 x 600
VESA
1024/75Hz 1024 x 768 1280/75Hz,50Hz 1280x1024
Timing
720 x 400
31.469 31.777 3.813 1.589 26.058 0.318 70.087 14.268 0.064 0.858 13.155 0.191 28.322
31.469 31.778 3.813 1.589 26.058 0.318 59.940 16.683 0.064 0.794 15.761 0.064 25.175
37.500 26.667 2.032 3.810 20.317 0.508 75.000 13.333 0.080 0.427 12.800 0.027 31.500
46.875 21.333 1.616 3.232 16.162 0.323 75.000 13.333 0.064 0.448 12.800 0.021 49.500
48.363 20.677 2.092 2.462 15.754 0.369 60.004 16.666 0.124 0.600 15.880 0.062 75.000
60.023 16.660 1.219 2.235 13.003 0.203 75.029 13.328 0.050 0.466 12.795 0.017 78.750
Separate Sync
Video C D E
Video Q R S
Sync-on-Green
Sync B A Sync P O
3-1 Disassembly
Cautions:1. Disconnect the monitor from the power source before disassembly. 2. Follow these directions carefully; never use any metal instrument except provided jig to separate the cabinet.
1. Place monitor face down on cushioned table and r emove 6 screws and remove stand.
2. Lift up the rear cover and remove 7 screws from the power board.
3-1
3-2
1. After confirm there is nothing on the desk, turn the LCD module over and put it on a flat desk set to the ground.
3-3
3 Disassembly and Reassembly 3. Slide the lamp unit out. Please take out the lamp unit from the LCD module.
4. Please fix the new lamp units on the LCD module : opposite process 2 and 3.
3-3 Reassembly
Reassembly procedures are in the reverse order of disassembly procedures.
3-4
3-4
4-1
4-2
4-3
4-4
8. Bus Stop
- Bus stop is used data communication.
9. Chcek Sum
- Display the current check sum size of the MICOM.
10. Reset
- Initializes the data in the MICOM.
Low
267 5, 263 5
x, y
x, y
4-5
4-2-4 Calibration
4-6
5 Troubleshooting
5 Troubleshooting
5-1 No Power
1
No
Yes
No
Yes
No
Check IC111.
Yes
No
Check IC112.
Yes
No
Check IC109.
5-1
5 Troubleshooting
No
Check IC104.
Yes
No
Check IC110.
Yes
No
Check IC108.
Yes
5-2
5 Troubleshooting
WAVEFORMS
5-3
5 Troubleshooting
No
WAVEFORMS
5-4
5 Troubleshooting
5-3 No Sound
Does the signal appear at Pin 110 (Tuner sound signal) and Pin 113, 114 (VCR sound) and Pin 115, 116 (DVD) Pin 117, 118 (PC) of IC802 (VCTj)?
No
(RF) Check Tu01 (TV Tuner). (Video) Check the CN913. (DVD) Check the CN901.
Yes Does the signal appear at Pin 123, 124 of IC802 (VCTj)? No
Check IC802.
Yes
No
Yes
5-5
8 Block Diagrams
8 Block Diagram
- This Document can not be used without Samsungs authorization.
8-1
8 Block Diagrams
8-2
10 PCB Layout
X
D941 D942 D945 D946 D947 D944
X
22.3 22.2 36.1 28.4 23.4 22.2
IC
IC600 IC601 IC902 IC903 IC108 IC110 IC900 IC705 IC805 IC703 IC704 IC109 IC706 IC500 IC501 IC300 IC105 IC112 IC101 IC111 IC-AUDIO AMP IC-AUDIO AMP IC-CMOS LOGIC IC-CMOS LOGIC IC-DC/DC CONVERTER IC-DC/DC CONVERTER IC-EEPROM IC-EEPROM IC-EEPROM IC-FLASH MEMORY IC-LCD CONTROLLER IC-POSI.FIXED REG. IC-REAL TIME CLOCK IC-VIDEO SWITCH IC-VIDEO SWITCH IC-VOL. DETECTOR IC-VOLTAGE REGULATOR IC-VOLTAGE REGULATOR IC-VOLTAGE REGULATOR IC-VOLTAGE REGULATOR 134.7 148.8 28.8 28.6 42.1 107.2 4.5 32.4 72.7 0.0 25.8 53.8 4.8 43.8 50.4 105.2 49.1 117.4 114.1 107.0 125.6 129.2 51.4 51.2 127.8 151.3 18.0 85.7 80.7 0.0 81.3 134.9 104.4 49.1 59.0 60.6 108.6 120.2 132.7 118.4
TRANSISTOR
Q200 Q600 Q601 Q602 Q603 Q800 Q902 Q100 Q101 Q104 Q805 Q810 Q900 Q901 Q801 Q802 Q803 Q804 Q809 TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL TR-SMALL SIGNAL 146.5 156.3 150.5 139.5 129.3 87.6 149.7 14.9 14.4 16.6 62.6 56.4 149.6 145.6 91.5 53.1 53.1 57.1 131.7 110.4 138.1 140.8 142.7 140.2 62.0 26.0 119.9 128.1 132.9 104.5 83.2 31.2 31.2 62.2 97.5 101.4 106.5 99.7
10-1
9 Schematic Diagrams
9 Wiring Diagram
9-1
11 Schematic Diagrams
11 Schematic Diagrams
- This Document can not be used without Samsungs authorization.
11-1
11-2
11 Schematic Diagrams - This Document can not be used without Samsungs authorization.
11-3
11 Schematic Diagrams - This Document can not be used without Samsungs authorization.
11-5
11 Schematic Diagrams - This Document can not be used without Samsungs authorization.
11-6
11 Schematic Diagrams - This Document can not be used without Samsungs authorization.
11-7