Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
2. Parameters
Technical Specification
Video Interface Audio Interface Video Compression Mode Audio Compression Mode Image Resolution Frame Rate Network Interface Network Protocol IP Address Transmission Bandwidth Alarm Output Clock Control Interface System Upgrade Operating Temperature Operating Humidity Output Voltage Power Dimension
1 BNC and 1 VGA video output RCA Interface: 1 Channel Audio Input, 1 Channel Audio Output H.264 G.726 720576 (1 picture) / 352288(4 pictures) 25 fps / 30 fps 10BaseT/100BaseTX Ethernet Interface TCP/UDP/HTTP/MULTICAST Support Static IP Address and Dynamic IP Analysis 64k3M bps 1 Channel Alarm Output (Contact Closure) Embedded Clock RS-485 Interface: 1 Channel 485 PTZ Control Support Remote Upgrade 050 2080% RHG DC 12V / 3A Less than 5Watt 180mm122mm44mm
3. Safety Instructions
Dont use the power supply with other voltages Dont open the housing of the product Cleaning Disconnect this video product from the power supply before cleaning. Attachments Do not use attachments not recommended by the video product manufacturer as they may cause hazards. Water and Moisture Do not use this video product near water, for example, near a bahtub, washbowl, kitchen sink, or laundry tub, in a wet basement, or near a swimming pool and the like. Only install this device and the power supply in a dry place protected from weather.
4. Physical Description
Power Input: DC 12V&3A Input: When the power supply is normal, the red light on. COM: Alarm Output GND NO: Alarm Output A: PTZ Control 485 Signal A B: PTZ Control 485 Signal B G: PTZ Control 485 Signal GND AUD IN: Audio Input AUD OUT: Audio Output VIDEO OUTPUT: Video output, BNC VGA: Video output, VGA RJ-45:10/100BASE-T, self-adapted RST: Reset button. Using a suitable pointed object, press and continue to hold the reset button depressed for 3 seconds when the power on.
5. Basic Connections
Follow the procedures below to connect the video decoder to the respective apparatuses.
1. The IP camera or other encoding devices as a video source. 2. The video server or other encoding devices as a video source. 3. Connect video server / IP camera and video decoder to and Ethernet hub 4. Video Decoder is the receiver side. 5. Connect a coaxial cable to TV monitor and display the video which encoded and transferred from video server / IP camera. Note: software installation and operation please refers to software user manual.