Standard Specification for
Penetration-Graded Asphalt Cement
AASHTO Designation: M 20-70 (2000)
Ww SCOPE
14. This specification covers the following five penetration grades of asphalt cement for use in
highway constraction: 40 to 50, 60 10 70, 85 to 100, 120 to 150, and 200 to 300. For asphalt
‘cements graded by viscosity, see AASHTO M 226, :
12 ‘The values stated in SI units are to be regarded as the standard,
2 MANUFACTURE ~
24. Asphalt cement shall be prepared by the refining of crude petroleum by suitable methods.
3. PROPERTIES
a4. ‘The asphalt cement shall be homogeneous, free from water, and shall not foam when heated to
17S G47).
32. ‘The various grades of asphalt cement shall conform to the requirements given in Table 1.
Table 1—Requirements for a Specification for Asphalt Cement
Pesciaton Onde
0-50 O70 #5-100 120-150 20-300
—Mig "Max Min Min Min Max Min MxM az
Fema SCOPD Hog Se 0 @ 100 tad 150 a0 a0
Fp, Ceeané pena, CF) eee SS ey Ss :
co & as) & om)
Dost 2°C (TPP, Scan cm eo ee oy ee
Sokbily niente, pean a a
This oven eet 3.2. Cin). IEC AST,
Show
esc ening percent - 8 = ow - ww sos
ewe fide, pesto gal e@ - # - » = « 2 | Ff
Desligetminen ICOM, Seances = — mm
‘ptt (viens a psd ie Noe) wit.
San apa ste Neate fora aes
‘Napiee sen pect, yee Nepstar i
Fepane rite stent pct aye Nepatve ea gaes
ot: “The we of pts is opna. Wen ts wed te eagle sal nine wit snared aphid lens Sphia glenssohond oe
‘plane aye solvent wil be ed in eeisig compass whe gure sad ie cas flee sohete Be aceon sete
tem
782 M20-7 ‘AASHTO4 METHODS OF SAMPLING AND TESTING
44, Sampling and testing of asphalt cement shall bein accordance with the following standard
‘methods of the American Association of State Highway and Transportation Officials:
m= 740, Sampling
‘T 44, Solubility in Trichloroethylene
7 48, Flash Point
749, Penetration
51, Ductility
755, Water
102, Spot Test
179, Thin-Film Oven Test
TS-25 M202 “AASHTO