Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
The new equipment has arrived for the remote Team-A office, and it is ready to be installed and tested. Team-A ordered an 1841 router to connect to the main Stadium Headquarters Edge3 router through a Frame Relay service provider network. They also ordered a backup DSL link through the ISP. The ISP router and simulated Frame Relay router should be configured by student. The ISP link has assigned IP addresses. A test plan for testing the new equipment and configurations in the NetworkingCompany lab has already been created.
1: Allocate blocks of addresses to each area of the network. VLSM and VLAN Plan
VLSM block size (Number of IPs) 512 (9 bits) N/A 256 16 64 128
Network Area Team-X block size to subdivide Edge3 Discovery Server local network Edge3 user local network (Sim Lo0) BR2 local network / VLANs VLAN 1 (Default/mgmt IP) VLAN 11 (Name: Dept-11, Ports 3-11 on switches S1, S2) VLAN 12 (Name: Dept-12, Ports 12-24 on
All contents are Copyright 19922008 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Network Area switches S1, S2) BR2 to Edge3 Frame Relay WAN link Total users and total block sizes
IP Address Plan
Device Name Edge3 Interface Fa0/0 Fa0/1 S0/0/0.101 Lo0 Fa0/1 Fa0/0 Fa0/0.1 Fa0/0.11 Fa0/0.12 S0/0/0.100 Fa0/0 Fa0/1 S0/0/0 S0/0/1 VLAN1 VLAN1 VLAN1 NIC NIC NIC 172.32.1.1/16 255.255.0.0 172.32.0.1/16 IP Address 172.32.0.1/16 172.17.1.6/30 172.16.1.210/30 172.16.0.1/24 172.17.1.2/30 172.16.1.193/28 172.16.1.129/26 172.16.1.1/24 172.16.1.209/30 172.17.1.1/30 172.17.1.5/30 DLCI 100 DLCI 101 172.16.1.194/28 172.16.1.195/28 172.32.0.2/16 Subnet Mask 255.255.0.0 255.255.255.252 255.255.255.252 255.255.255.0 255.255.255.252 255.255.255.240 255.255.255.192 255.255.255.0 255.255.255.0 255.255.255.252 255.255.255.252 N/A N/A 255.255.255.240 255.255.255.240 255.255.0.0 Default Gateway N/A
BR2
N/A N/A N/A N/A N/A N/A N/A 172.16.1.193/28 172.16.1.193/28 172.32.0.1/16
Identify the steps necessary to configure each piece of equipment to perform each test. List only the configuration steps needed to complete the test. Be sure to specify the device name and what is to be configured.
All contents are Copyright 19922007 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 2 of 5
Specify just the key items and interfaces to be configured. It is not necessary to include the exact commands and every IP address. For each step under the configuration requirements, first identify the device being configured and then the item to be configured. Use as many lines as necessary. The final step in each set of installation test requirements specifies to perform the test as described in the test plan.
Step No. 1 2 3 4 5 6 7 8
Devices
Step No. 1 2 3
Devices
All contents are Copyright 19922007 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 3 of 5
Step No. 1 2 3
Devices
c. Record the output of the debug eigrp packet command on the Team-A router to verify MD5
authentication.
d. Record the router output of the show running-config and show ip route commands.
e. Record the router output for the Frame Relay circuit using the show frame-relay map, show frame-relay pvc, and show frame-relay lmi Goals of Test Verify that the Frame Relay link to the Stadium network is functional, the EIGRP routing protocol is properly configured with MD5 authentication, and the correct static routes are configured. 3. commands.Backup Link Configuration
a. Configure floating static routes on the Team-A and Stadium Network routers to the Discovery
Server through the ISP router. b. Cause the Frame Relay link from BR2 to SP-FR to fail by shutting down the Serial 0/0/0 interface on BR2.
All contents are Copyright 19922007 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information. Page 4 of 5
c. Display the routing table for BR2 and Edge3 using the show ip route command to verify that
the floating static route through the ISP is installed in the routing table. d. Ping from the hosts H1 and H2 to the Discovery server at URL http://server.discovery.ccna or IP address 172.32.1.1. Goals of Test Verify that the backup DSL link from the Team-A router BR2 through the ISP router to the Stadium Network is activated if the primary Frame Relay link fails. 4. ACL Filtering
a. Configure an ACL on the Team-A router BR2 and the Stadium Edge3 router to control traffic as
described in the Test 4 goals. b. Telnet to BR2 from any host other than Edge3, and then telnet from Edge3 to BR2.
All contents are Copyright 19922007 Cisco Systems, Inc. All rights reserved. This document is Cisco Public Information.
Page 5 of 5