Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
LO 5-3825-270-13
ENGINEER MISSION MODULE - WATER DISTRIBUTOR (EMM - WD) NSN 3825-01-577-2713 PN 5251894 CAGEC 80195
References: TM 5-3825-270-10 and TM 5-3825-270-23&P
REPORTING OF ERRORS You can help improve this publication. If you find any errors, or if you would like to recommend any improvements to the procedures in this publication, please let us know. The preferred method is to submit your DA Form 2028 (Recommended Changes to Publications and Blank Forms) through the Internet, on the Army Electronic Product Support (AEPS) website. The Internet address is http://aeps.ria.army.mil. The DA Form 2028 is located under the Public Applications section in the AEPS Public Home Page. Fill out the form and click on SUBMIT. Using this form on the AEPS will enable us to respond quicker to your comments and better manage the DA Form 2028 program. You may also mail, e-mail, or fax your comments on DA Form 2028 directly to the U.S. Army TACOM Life Cycle Management Command. The postal mail address is U.S. Army TACOM Life Cycle Management Command, ATTN: AMSTA-LCL-MPP / TECH PUBS, 6501 E. 11 Mile Road, Warren, MI 48397-5000. The e-mail address is: tacomlcmc.daform2028@us.army.mil. The fax number is DSN 793-0726 or Commercial (309) 782-0726. A reply will be furnished to you.
DISTRIBUTION STATEMENT A. Approved for public release: distribution is unlimited. NOTICE. Copy of this lubrication order will remain with the equipment at all times; instructions contained herein are mandatory.
Card 1 of 8
LO 5-3825-270-13
NOTES:
LUBRICATION ORDER
This LO is for crew (C) or field (F) maintenance. Lube intervals (on-condition or hardtime) are based on normal operation. Lube more during constant use, and less during inactive periods. The water distributor is not designed for use in temperatures below 33 F (0.56 C) or higher than 122 F (50 C), therefore, the same grade lubricants should be used at all time. When using a grease gun, apply lubricant to the fitting until clean lubricant squeezes out of the part being lubricated. Clean parts with dry cleaning solvent (SD), type II, or equivalent. Dry before lubricating. Wipe surfaces dry. Before you start your lube service.
ALWAYS a. Clean grease fittings before lubrication. b. Use the lubrication order as your guide. NEVER a. Use wrong type/grade grease. b. Use too much lubricant.
For equipment under manufacturer's warranty, hard time oil service intervals shall be followed. Intervals shall be shortened if lubricants are known to be contaminated or if operation is under adverse conditions such as longer than usual operating hours, extended idling periods, extreme dust, etc.
Table 1. Lubricants.
Approximate Capacity As Required As Required OC-ON-CONDITION D - DAILY W - WEEKLY M - MONTHLY S - SEMIANNUALLY (6 MONTHS) A - ANNUALLY B - BIENNIALLY
Component Manhole Cover Stowage Box Hinge Air Lubricator Water Pump
Intervals
Engine Oil (EO): Engine Oil (EO): 15W -40 OE/HDO-30 MIL-PRF-2104 MIL-PRF-2104
Engine
14 qts (13.2 L)
Card 2 of 8
LUBRICATION ORDER
LO 5-3825-270-13
Table 2. Other Fluids.
Capacity As Required 14 qt (13.25 l) Temperature All Temperatures
Fluid Dry Cleaning Solvent Antifreeze, Ethylene Glycol (A-A-52624, Type 1B)
All Temperatures
Intervals OC-ON-CONDITION D - DAILY W - WEEKLY M - MONTHLY S - SEMIANNUALLY (6 MONTHS) A - ANNUALLY B - BIENNIALLY H - HOURS
Card 3 of 8
LO 5-3825-270-13
LUBRICATION ORDER
Card 4 of 8
LUBRICATION ORDER
LO 5-3825-270-13
Card 5 of 8
LO 5-3825-270-13
LUBRICATION ORDER
Card 6 of 8
LUBRICATION ORDER
LO 5-3825-270-13
Card 7 of 8
LO 5-3825-270-13
LUBRICATION ORDER
Card 8 of 8
By Order of the Secretary of the Army: MARTIN E. DEMPSEY General, United States Army Chief of Staff Official:
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
DISTRIBUTION: To be distributed in accordance with the initial distribution requirements for IDN 257864 requirements for LO 5-3825-270-13.
PIN: 086770-000