Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
conversion including what parts I need and what steps. It was pretty much pointless to keep
looking online. A friend of mine sent me to a link and im going to share it with everyone cuz I
know it was a bitch looking for help. This is for the people who where in my shoes before the
conversion (STUCK) so here you go. Hope it helps.
Parts could cost anywhere between $230-$405 depending on what kinds of deals you can find
and where you get them from, it may also be cheaper if you buy everything from one person
all at once
It is much easier to use your existing DPFI harness and just add the extra 4 wires that will be
needed. The Si harness will be much harder to use.
There are two major wiring changes that you'll have to do going from a DPFI system to an
MPFI and a couple other minor things that need to be done too. The first one is the crank
angle sensor wiring which is the easy part. The second one is the fuel injector wiring which is
slightly more complicated. Also, you'll have to switch the two wires on the TPS because the
TPS on the new intake works in the opposite direction. If you dont switch them, the ECU will
think that the engine is at Wide open throttle when its actually at idle. I highly recommend
soldering and heat shrinking any electrical connections you will be making because it is very
possible for connectors to come loose from all the vibration and solder will hold up better in
the long run. Also, the TPS and EACV plugs are too short and they'll have to be extended.
You're also going to have to switch the manifold support bracket, since the bolt parrern from
the support to manifold is different from DX to SI, although they still bolt up on the block the
same.
INJECTOR WIRING
(In the car):
First of all, while you're still in the passengers footwell, cut wires A3(yellow) and A7(red),
although leave some wire on the ECU side for later use. Now run wires from pins A3 and A7
into the engine compartment and label them.
(Engine Compartment):
- Mount the injector resistor box up on the drivers side shock tower.
- Connect the yellow/black wires from the two DPFI injector harnesses and run it to the
yellow/black wire on the injector resistor box.
- Connect the yellow wire from the DX injector to the #1 injector (brown wire).
- Connect the red wire from the DX injector and run it to the #3 injector (blue wire).
- Connect the wire you labelled A3 to the #2 injector (red wire).
- Connect the wire labelled A7 to the #4 injector (yellow wire).
- Then, connect the 4 red/black wires coming from injector resistor box to each of the four
injectors.
You should have three extra plugs left over after you are done the swap. two of them are the
old DPFI injector plugs, and the other one is for the tandem vavle for the DPFI system, which
you do not use on the MPFI system, you can either just cut it off, or tuck it away somewhere.
OBD1 ECU PINOUT
The # go up and down from left to right.(see)
Another thing make sure you have extra pin inputs since you will cutting the wire and not
taking the complete wire out of its socket.