Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
- "To promote the board to return" when rolling towards the end, avoiding because of own weight,the
plate end was crushed into the roller then flatten.
-When the roll at the end of the process to locate both ends of the plate for welding (1.5.1).
- Formal support also with roller to support simultaneously tilt the plate.
In other types of machines, all of these operations will be done by the crane, which not only waste a
lot of time lost, but slso the implementation will be difficult.
Vertical support (1.8), with a steering roller to support the plate to maintain the correct diameter
during the entire roll, but not with the crane.
3 - Through rising lower roller until it rolls up under the pressure of top roller and clamping plate
closer (2.3)
5 - Move plate back, about reaching the two center roller’s axis
position (2.5)
6 - Pre-bending stage:
a) Tilts the left pressure roller (2.6.1). tilted values must be found by experiment or experience.
Because the bending machine is equipped with CNC system, this value has been calculated
according to the nature of the previous board out, rolling parameters can be set in accordance with
the implementation. However, these values are theoretical,just a referene to the operator.
c) To figure (2.6.3) rising support in such a way to support the weight of plate.
e) Move forward the plate to over the axis of right side roller
(2.6.5).
If the diameter is less than the required diameter,it must rotate the plate back to the starting position
then re-forward spin, and check to fix the defect diameter
(2.6.5.2). In this action the board will be opened again because
of its own weight.
f) Plate bending is now complete. Continue to decline the feed platform, the left front support and
pressure roller at this point (2.6.6).
Note: The left side roller position (2.6.6.3) must not be completely dropped, and in the high then
7 - Coiled sheet:
a) Tilt the right side roller (2.7.1). Tilted number is found by
testing or experience of the operator.
Because the bending machine is equipped with CNC system,
this value has been calculated according to the nature of the
previous board out, rolling parameters can be set in
accordance with the implementation. However, these values
are theoretical,just a referene to the operator.
b) Rising the right roller (2.7.2) to the right place to get the desired diameter.
c) Fully fall the down pressure roller (2.7.3) and set the bending machine to "re-rolling" mode
(correction), only has the power to the upper roller.
i) Continue to roll until the end plate near the front edge of
support.
c) Rising the right roller to the right position (2.8.3), it is because the left roller has been carried out
to roll the plate, but from now on, need to use the right roller to
complete the final rolling.
d) When the plate reaches the center of the two pressure roller,
the rolling process is completed.(2.8.4)
At this point:
- Carefully clean the accumulation of any waste in the plate.
- Down the right side roller, pulling back the plate,makes its pressure on the left roller.