Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
AND
INSTRUC IONS
H AVV DUTV ON WH
& INDLES
8-0493
Printed In U.S.A. 0188 PART NO. B10S04R1
DESCRIPTION Install supplied heavy duty wheel and tire as-
sembly on each new spindle using removed shims and
This Heavy Duty Front Wheel Spindle Kit is de-
supplied coffer pins as shown in Fig. 2. NOTE: ON
signed for use with all 1974 and later C-Series and
PRIOR YEAR MODELS USING BOLTS TO RETAIN WHEEL
400-Series tractors. It may also be used with 1976
AND TIRE ASSEMBLIES, DISCARD BOLTS AND T,HICK
and 1977 B-80 8-Speed and 8-100 8-Speed models.
WASHERS AND USE PIN 920015 3/4 SAE WASHERS
AND SUPPLIED COTTER PINS. Wheel and tire assembly
is installed with valve ster)'l to inside of tractor. Cor-
INSTALLATION
rect end play is 0-.015 in.! .4mm. In some cases, it may
Raise front of tractor using a suitable floor jack be necessary to add or remove shim washers. Install
or overhead chain lift and support with jack stands. supplied hub caps on wheels. When tractor is to be
Remove hub caps and snap rings, bolts or cotter pins used with a bucket loader, adjust all four tire pres-
retaining wheel and tire assemblies to spindles. Re- sures to 25-30 PSI (1.8 to 2.1 Kg/cm2).
move wheel and tire assemblies and all washers from
front spindles. Remove nuts securing tie rods to front
spindles. Remove snap rings, E-Rings or cotter pins
from top of spindles and remove spindles from front
axle.
.050" (Thick) Shim Washer
Locate two supplied heavy-duty spindles and eight
I
1Ya',o.D.washer
washers. Install one thin washer followed by a me-
dium thick washer on each spindle (Fig. 1). Install two Cotter Pin
~~,#/
/
thick coated washers on each spindle so that smooth /HubCa p
coated surfaces of washers face each other. Insert l)
spindles into front axle and retain using supplied
retaining rings and removed washers from original
spindles. Install fie rods to new spindles and secure
using removed nuts.
FIG. 2. Install Heavy Duty Wheels and Tires
Thin Washer - - - - -
New Spindle---
-1-
PARTS LIST FOR HEAVY DUTY FRONT WHEELS AND SPINDLES KIT
FACTORY ORDER NUMBER 8-0493
When ordering parts always list Part No. and Description.
Parts available only through Authorized Dealers.
(Specifications subject to change without notice.)
-2-