Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Due to developments in technical standards and the equipment described in this document, we cannot be held liable for compliance with the characteristics indicated by the images and text unless they are confirmed by us. All the brand names referred to in this document are protected by copyright.
be installed upstream of the installation (at
at the design stage. an insertion point near the connection with
In existing installations, an expert should the power supply distribution system),
visit the site in order to carry out a full ◗ or a reduction of the level
Terminal
distribution Active conditioner audit with measurements of: of pollution in the installation
◗ harmonic currents, In this case, the purpose is to neutralise
◗ cos ø, particularly in case of IT servers. the harmonics as close as possible to
the principal source of non-linear loads.
Active conditioner The active conditioner(s) should then be
Diagram of the low voltage distribution circuit, showing located downstream (secondary or terminal
the various installation points for an active conditioner
depending on the required level of neutralisation.
distribution system).
Technical characteristics
Model SW20 SW30 SW45 SW60 SW90 SW120
Main features Compensation capacity per phase 20 A rms 30 A rms 45 A rms 60 A rms 90 A rms 120 A rms
◗ Global compensation or individual Compensation capacity in the neutral(1) 60 A rms 90 A rms 135 A rms 180 A rms 270 A rms 360 A rms
harmonic compensation, from H3 System input
to H50 (selectable), Nominal voltage(2) 400 V - 20 + 15 %
Nominal frequency 50Hz, 60 Hz, +/- 8 %
◗ correction of the displacement power
Number of phases 3 phases with or without neutral
factor, cos ø (adjustable),
(operation is possible with single-phase or unbalanced loads)
◗ configuration for types of load:
Current transformers range from 300/1 to 4000/1
computer loads, rectifier, etc.,
Technical characteristics
◗ IGBT technology and control Compensated harmonic currents H3 to 50, full equalisation or individual equalisation
by DSP circuit, Harmonic attenuation rate THDI load /THDI system less than 10, at the nominal rating of the equaliser
◗ 3 LEDs to indicate operating condition, Correction of cos ø lagging or leading, up to 1.0
◗ digital 7-language display unit, Response time < 40 ms
Publication: MGE UPS SYSTEMS (July 2006) - Design and rewriting: 3c-evolution.com - Integration: Pamplemousse: +33 4 79 37 87 66 – Translation: TTP: +33 4 78 66 47 99.
◗ configuration and parameter Overload Limitation of the nominal current, possibility of continuous operation with current limitation
assignment menu, Inrush current < 2 x the nominal peak current
◗ remote control (lockable), Heat losses 1000 W 1300 W 2100 W 2600 W 4200 W 5200 W
Acoustic noise (ISO 3746) < 55 dBA < 55 dBA < 60 dBA < 60 dBA < 65 dBA < 65 dBA
◗ redundancy parallel connection facility,
Colour RAL 9002
◗ wide range of current transformers, etc.
Environmental conditions
Operating temperature 0 to 30°C continuous, <25°C recommended
Associated communication
Relative humidity 0 to 95 % without condensation
JBus/ModBus card (optional) Operating altitude < 1000 m
To connect the SineWave to a building Reference technical standards
management system. Construction and safety EN 60950-1
Status information card Design IEC 146
To relay the status of the SineWave via Protection IP 20 conforming to IEC 529
3 volt free contacts. EMC
Conducted and radiated emission EN 55011 level A
MGE PowerServices™ Immunity to electrostatic discharge IEC 61000-4-2 level 3
Immunity to electromagnetic fields IEC 61000-4-3 level 3
1-year warranty. Immunity to impulse waves IEC 61000-4-4 and IEC 61000-4-5 level 4
Associated services (1) 1: Maximum capacity with PC-type data processing load and with three-phase balanced supply.
2: Other voltages - 208 V, 220 V, 480 V - available on request.
◗ Commissioning: setting up the
SineWave in conformity with your
installation,
◗ Teleservice: remote monitoring
via the telephone system,
◗ Maintenance contracts: a selection 315
Headquarters
140, avenue Jean-Kuntzmann
Inovallée - Montbonnot Saint-Martin
38334 Saint-Ismier Cedex - France
Tel.: +33 (0)4 76 18 30 00
SINW023UK-07/06