Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
you
Medical Products
Clothing and Gloves
from own production
Welcome!
Dear Customer,
Yours sincerely
Sänger GmbH
Table of Contents
Examination Gloves Latex, non-sterile 8-12 Softimol Bed Protection, Disposable Bed Sheet 46
Examination Gloves Vinyl, non-sterile 16 Plasters, Sport Tape, Pretape, Cohesive Bandage 50-53
Examination Gloves Polyethylene, non-sterile 17-18 Cooling and Heating Products 54-55
Clothing, sterile 41
Class I Category I
Low level of invasiveness, temporary use For areas with low risk
Med I PSA I
Additionally our products are tested according to
Class Is the following standards:
Low level of invasiveness, temporary use,
Category II
1234 For areas with medium risk, EC-model
Med Is sterile; independent evaluation 1234
PSA II testing
Class IIa
Category III
AQL AQL (Accepted Quality Level)
According to Norm EN 455 and ISO 2859-1 there is a quality management requirement on spot
Moderate level of invasiveness, temporary 1,5 tests. It is tested for defects, permeability and physical qualities and there are several quality levels
1234
use, sterile; independent evaluation For areas with high, irreversible or fatal risk,
Med IIa 1234 (<0,65; <1,0; <1,5; <2,0; <4,0), with a lower value standing for higher quality.
PSA III EC-model testing
Class IIb
Systemic effects, long-term use; independent FDA Standard
1234 Tested with the FDA (Food and Drug Administration) 1000 ml water hold test for medical gloves.
Med IIb evaluation
OSHA Standard
Additionally protective clothing and gloves are marked with Complies with the OSHA (Occupational Safety and Health Administration) Standard for Hand
the following pictograms, according to each norm: Protection.
General requirements for gloves General Requirements for disposable
(according to EN 420) medical gloves (according to EN 455)
ICRP & ICRU Tested
Instruction manual Conform to the suggestions in ICRP (International System of Radiological Protection) Report #60
Protection against microorganisms
(according to EN 374) and ICRU (International Commission on Radiation Units and Measurements) Report #51 concer-
(according to EN 374)
ning radiation protection gloves.
Protection against chemical hazards High protection against chemical hazards
(according to EN 374-1:2003, 5.2.1) (according to EN 374-1:2003, 5.2.1 and 5.3.2)
EN 14683
Protection against ionizing radiation Conform to EN 14683 Type II norm for surgical masks.
Protection against radioactive particle conta-
(according to EN 421) mination (according to EN 421)
AQL
0197
PSA II
1,5
Med I
light yellow
28 cm
PROFI
Size Art.-No. CHEMOTEX textured
extra small (5 - 5½) 01 140 Size Art.-No.
small (6 - 6½) 01 141
Standards: Standards:
small (6 - 6½) 01 281
medium (7 - 7½) 01 142
large (8 - 8½) 01 143 AQL medium
large
(7 - 7½)
(8 - 8½)
01 282
01 283 AQL
extra large (9 - 9½) 01 144 0197
1,5 extra large (9 - 9½) 01 284 0197
Packing: 100 pieces per dispenser box
Med I PSA II
Packing 50 pieces per dispenser box PSA II
1,5
Med I
10 dispensers per outer carton 10 dispensers per outer carton
■ Textured Surface
■ Inner Aloe-Vera
Standards: ■ Inner and Outer Chlorinated
AQL
0197
PSA II
1,5
Med I
GRIFF smooth
Size
extra small (5 - 5½)
Art.-No.
01 130
Alfatex universally usable
small (6 - 6½) 01 131
medium (7 - 7½) 01 132
large (8 - 8½) 01 133 This Nitrile glove is suited for a variety of
extra large (9 - 9½) 01 134 situations, and serves to handle chemicals.
Packing 100 pieces per dispenser box The textured surface guarantees good grip
10 dispensers per outer carton as well as tactile properties.
natural
■ Latex Free
24 cm ■ Powder Free
■ Textured Surface
Standards:
AQL
0197
PSA II
1,5
Med I
FINGER COTS powder free ERIS The black coloured Eris glove reduces light re-
Size Art.-No. Size Art.-No. flections, making it ideal for laser treatments.
small 01 471 small (6 - 6½) 01 851
medium 01 472 medium (7 - 7½) 01 852
large 01 473 large (8 - 8½) 01 853
extra large 01 474 ■ Powder Free
extra large (9 - 9½) 01 854
Packing: 1440 pieces per polybag Packing: 100 pieces per dispenser box ■ Textured Surface
10 dispensers per outer carton ■ Inner and Outer
Standards:
chlorinated
black
24 cm
Med I
blue
■ Inner and Outer Chlorinated NEOTRIL textured
30 cm ■ Textured Surface Size Art.-No.
extra small (5 - 5½) 01 770
small (6 - 6½) 01 771
Standards: medium (7 - 7½) 01 772
0197
AQL extra large
Packing:
(9 - 9½) 01 774
100 pieces per dispenser box
Med I PSA II 1,5 10 dispensers per outer carton
purple
The new Betatex glove 25 cm
provides good protection
while being well-priced, ideal
for the use in areas where
large quantities of gloves are
required. The textured surface Chemotril
guarantees good grip and
good tactile properties.
Standards: Extra strong, extra long Nitrile disposable CHEMOTRIL
gloves with extra mechanical strength and Art.-No.
■ Latex Free
AQL for high risk areas. Textured fingers and a
Size
small 6 - 6 ½ 01 291
■ Powder Free 1,5 medium 7 - 7 ½ 01 292
Med I PSA I beaded cuff add to extra resilience of this
■ Textured Surface gloves. large 8 - 8 ½ 01 293
x-large 9 - 9 ½ 01 294
Ambidextrous, comfortable fit, strong tear xx-large 10 -10 ½ 01 295
resistance, free of latex and latex proteins, Packing: 50 pieces per dispenser box
BETATEX textured BETATEX textured BETATEX textured powderfree. Resistant to almost all cytoto- 10 dispensers per outer carton
Size Art.-No. Size Art.-No. Size Art.-No.
xic chemicals.
extra small (5 - 5½) 01 575 extra small (5 - 5½) 01 395 extra small (5 - 5½) 01 375
small (6 - 6½) 01 576 small (6 - 6½) 01 396 small (6 - 6½) 01 376 Free of silicone make the gloves suitable blue
medium (7 - 7½) 01 377 30 cm
medium (7 - 7½) 01 577 medium (7 - 7½) 01 397 for many industrial applications. Excellent
large (8 - 8½) 01 578 large (8 - 8½) 01 398 large (8 - 8½) 01 378
conductivity.
extra large (9 - 9½) 01 579 extra large (9 - 9½) 01 399 extra large (9 - 9½) 01 379
Packing: 150 pieces per dispenser box Packing: 150 pieces per dispenser box Packing: 150 pieces per dispenser box Standards:
10 dispensers per outer carton 10 dispensers per outer carton 10 dispensers per outer carton
AQL
0321
blue purple white Med I PSA III
1,5 JKL
24 cm 24 cm 24 cm
Vinyl Polyethylene
Polyvinylchlorid (PVC), more commonly know as Vinyl, is a thermoplastic polymer. In order to make Vinyl usable Polyethylene (PE) is a versatile thermoplastic polymer. In its basic form it is transparent. PE gloves are manufac-
for gloves and other products, it is mixed with plasticizers. It does not contain any Latex proteins. Vinyl is cheap to tured by sealing two thin film PE foils to the shape of a glove. PE gloves are especially suitable for the food indus-
manufacture, but the decision for a Vinyl glove should be taken with care. Vinyl is not very elastic, which can ne- try. Using PE gloves in areas with a high risk factor is not recommended. All disposable gloves made of polyethyle-
gatively influence fit and resistance against biological hazards. Vinyl gloves should only be used in areas with a low ne are ambidextrous and thiuram-free.
risk factor. All Sänger disposable gloves made of Vinyl are ambidextrous, thiuram-free and have a beaded
cuff edge.
Standards: transparent
The Pretex glove is made out of soft, tear-
approx. 29 cm
resistant Vinyl. It is suited for lighter work,
like for example nursing care but can also Standards:
be used in combination with chemicals.
AQL PSA I
AQL 30 cm
transparent
Standards: approx. 55 cm
transparent
0197
1,5
Med I PSA II
PSA I
PSA I
The white metal holder for dispenser boxes
of Sänger disposable gloves has additional
space to store hand care products like
OP-SeptBasic (page 27) or Sänger Derma
Wall Shelf Lotion (page 30). The Hand Care Centre al-
lows easy access at work or at home. Can
be positioned on a surface or mounted on
a wall with included set.
WALL SHELF
An aluminium shelf for polyethylene gloves
Art.-No.
HAND CARE CENTRE
in women and men size. It can be adhered complete with wall mounting set
04 917
to smooth surfaces by double sided adhe- Art.-No.
sive tape. Light-weight and complete with Size: Width 24 x height 15 x depth 1.5 cm 04 914
wall-mounting set.
Size of metal hand care centre:
L: 37.5 cm x H: 8.5 cm x D: 9 cm
■ Nitrile
■ Latex free
Eko for surgery
■ Packed in pairs STERILE R
■ Powder free The Eko glove has the same material as the Pluto
■ Textured surface glove. The glove is lightly powdered with non-
allergic food grade corn starch to provide easy
■ Ambidextrous
donning.
■ Natural rubber latex
■ Lightly powdered
ALFATEX STERILE packed in pairs
Size Art.-No. ■ Polyurethane coating
small (6 - 6½) 01 176 ■ Micro-textured surface
medium (7 - 7½) 01 177 ■ Fully anatomically shaped
large (8 - 8½) 01 178
extra large (9 - 9½) 01 179 ■ Sterile
Packing:
2 pieces of gloves sealed in a sterile pouch. EKO lightly powdered
50 pairs per dispenser box Size Art.-No.
10 dispensers per outer carton blue
24 cm 6 01 350
6½ 01 351
7 01 352
½ 01 353
Standards: 8 01 354
8½ 01 355
AQL Packing:
0124 0197
1,5 1 pair of gloves packed in a medical grade
Med Is PSA II
paper wrapper and sealed in a sterile pouch.
50 pairs per dispenser box
4 dispensers per outer carton
STERILE EO Standards:
natural
AQL
0481
28,5 cm
PSA I
0,65
Med IIa
AQL AQL
Primary glove: brown
Secondary glove: yellow
0123
PSA I
1,5 0123
1,5
Med IIa Med IIa PSA I 30 cm
STERILE R
This extra long and extra thick sterile
examination glove is suited for gynae-
The Maxitex Neuro PF sterile surgical cological areas, like underwater births.
glove is made of natural rubber latex and A special surface treatment makes it
coated with Polyurethan, offering excel- easy to don and gives very good tactile
lent tactile properties. The micro-textured properties. The textured surface on
surface allows safe use with instruments, hand and fingers provide good grip.
even in wet environments. The brown
colour reduces light reflections.
t dem g
Gr
sterile pouch.
ip!
extra gri
100%
mi
aus vorbildlich
th
bewirtschafteten Wäldern
NEW
wi
d
an
PSA I it
Ro
llr Material Properties:
m
Type Thickness Lead Equivalence
RR-1 0.22 ± 0.02 0.016 mm Pb
Radiaxon
Rubber gloves suitable for working in the RADIAXON
housekeeping area. A doubled coating PRIMAGRIP with zig-zag cuff ■ natural rubber latex Sterile disposable glove mainly used for di- Size Art.-No.
grants extra protection and it can be used Size Art.-No. ■ lead free and non-toxic agnostic heart catheterization, coronary an- 6½ 01 911
with a variety of disinfectants and chemi- small 11 101 gioplasty, angiocardiography, gynaecology, 7 01 912
■ powder free
cals. medium 11 102 urology, orthopaedics etc. 7½ 01 913
■ anatomically shaped The purpose of this radiation protective 8 01 914
large 11 103
■ Natural Rubber Latex extra large 11 104 ■ thickness: min. 0.30 mm glove is to protect the hands from scattered 8½ 01 915
■ micro-textured surface secondary radiation exposure originating 9 01 916
■ Textured Surface Packing: Each pair is packed in a polybag
with Euro-hole and EAN bar-code. from the x-ray beam during fluoroscopic Packing:
■ Anatomically Shaped ■ for single use
10 pairs per master polybag procedures. This glove is not intended for 1 pair of gloves right/left packed in a medical grade
■ Velour inner lining ■ superior tactile properties use in the direct or primary x-ray beam. paper wrapper and sealed in a sterile pouch.
■ tear resistant Excellent grip on instruments. For single use. 5 pairs per dispenser box
yellow
30 cm ■ rolled cuff edge
olive
■ low protein contents 29 cm
Standards:
Standards:
AQL
0498
Med IIa
0086 1,5 0010 ABCGKL
PSA II
PSA I
Glove Liners
Seamless knitted nylon gloves, ambidex- ■ 100% Nylon DISINFECTION TRAY
trous are comfortable to wear alone or in- ■ Machine washable Capacity Size Art.-No.
side other gloves. Reduced sweating under- ■ Ambidextrous 0.1 Liter for small parts dia Ø 85 x 40 mm 04 295
neath examination gloves. Tactile properties 1 Liter 223 x 149 x 91 mm 04 291
do not become affected due to half fingers NYLON KNITTED UNDERGLOVES 3 Liter 300 x 210 x 115 mm 04 290
and open, uncovered finger tips. Size Art.-No. 5 Liter 315 x 206 x 125 mm 04 292
Colour: white Universal 01 588 10 Liter 496 x 328 x 195 mm 04 293
Packing: each pair in a polybag 10 Liter for Endoscopes 870 x 235 x 160 mm 04 294
with outlet hose
Art.-No.
Sänger disposable surgical masks are made
02 108
of a non-irritating, soft, light weight, non- PAPER FACE MASKS
Packing: 50 pieces per dispenser box Standards:
woven material for optimum comfort. Colour Art.-No.
Ideal fit due to long, formable inner nose 20 dispensers per outer carton
white 02 105
bridge. Sänger 3-layer surgical masks have blue
■ one layer Packing: 100 pieces per dispenser box
a 99.6% filter effect and are free of glass Med I
particles and latex. Non-sterile. Standards: ■ with elastic ear loops 100 dispensers per outer carton
■ 100 pieces per dispenser box
with opening for easy removal
Med I
WITH STRINGS FOR TYING
Art.-No.
02 107
Mask Nik FFP3
Packing: 50 pieces per dispenser box
20 dispensers per outer carton Nik
blue Class Art.-No.
FFP3 02 131
Product features as mask Nik with addition- Packing: 10 pieces per box
Standards: al comfort due to exhalation valve. 40 boxes per outer carton
EN 149:2001 A1:2009
Med I Standards:
PSA I
Sänger Face Masks Surgical Caps One-way Nurse Caps PLATE TYPE
One way nurse caps with circular elastic.
with eye shield and non-woven material
Size
green
Art.-No.
Med I
+R One-Way Nurse Caps PLEATED
Pleated nurse caps packed in polybags, easy
removal. Air permeable material.
WITH EYE SHIELD, ANTI-GLARE-SYSTEM Size Art.-No.
green
with strings for tying
medium 02 201
Art.-No. 02 138
white
Standards:
medium 02 208
Packing: 25 pieces per dispenser box
blue
4 dispensers per outer carton
Med I medium 02 209
pink
blue
medium 02 703
red
medium 02 702
Sänger Face Masks with eye shield Packing: 100 pieces per polybag
5 polybags per carton
universal 02 701
with elastic ear loops
Art.-No. 02 104 254 Packing: 100 pieces per polybag
5 polybags per carton
Packing: 25 pieces per dispenser box
4 dispensers per outer carton
white
Standards:
Med I
Disposable Gown
PE-Apron with White, non-sterile, non-woven material
DISPOSABLE GOWN
Size Art.-No.
Arm Sleeves for single use, i.e. visitors, medical staff
or patients, etc. With two ties at the hip
x-large white 02 248
Sleeve Covers
Strong water resistant polyethylene and at the neck to close the gown at
xx-large white 02 249 SLEEVE COVERS
foil. Blue, textured surface, non- Made of strong polyethylene foil, with elas- Colour Art.-No.
the back. Each piece in a polybag.
transparent. With neckband and two Packing: tic at both ends. white 02 218
Each piece in a polybag
strings for tying at the waist. With blue 02 219
50 pieces per outer carton Packing:
small thumb hole to ensure gloves will
cover the arm sleeves to securely keep 50 pieces per polybag
out any splashing liquids or other con- 40 polybags per outer carton
taminating material. Ideally suited for
Standard:
disinfecting instruments in liquid. For
one-way use.
Standards: Med I
Med I
Shoe Cover Box
Disposable Panties
50 pieces per outer carton
Disposable Overall
Made of non-woven material with DISPOSABLE PANTIES
elastic on waist and legs. Light, soft Size Art.-No. Cosmo
and air permeable. For one-way use. XL 02 215
Reinforced section up to the waist. Water resistant overall made of waterproof-
(59 x 70 cm)
Non-sterile. coated polypropylene. Comfortable to
XXXL 02 216
wear. Several sizes for excellent fit.
(66 x 75 cm)
Available with elastics at cuff, hood and
Packing: legs. Zip fastener at the front. Available in 4 WORKING GOWN
50 pieces per polybag sizes for comfortable fit. Soft, strong, non- Size Art.-No.
20 polybags per outer carton fluff white colour material with very good x-large 02 192
resistance to abrasion. Protects against xx-large 02 193
many chemicals, paints, dust etc. Ideal to Packing:
have in any emergency body protection kit. 5 pieces in a polybag
Suitable for laboratories, industrial work. 50 polybags per outer carton
PE GOWN
PE Gown Type Art.-No.
Beard Cover
PE gown
White colour transparent polyethylene with collar 02 113
gown with push buttons in front. Available PE gown
with hood or with collar. Ideal protective with hood 02 114
clothing for visitors, for protection of cloth
against wet, dirt and odour. Packing:
Non-woven, white, with rubber band, BEARD COVER Colour: white/transparent. PE gown: Each piece in a polybag
Size Art.-No. 10 pieces per master polybag
breathable.
53 x 22 cm 02 237 500 pieces per outer carton
Packing:
DOCTORS JACKET Without wet protection zone: Each piece in a polybag, 50 pieces per carton
Size Art.-No. With wet protection zone: Each piece in a polybag, 40 pieces per carton
Universal 02 247
Doctors Gown STANDARD non-sterile
Packing: Each piece in a polybag, Material: SMS hydrophobic material made of 100% polypropylene non-woven
50 pieces per carton textile 50 g/sqm, 3-layer structure spunbond-meltblown-spunbond, blue.
without wet protection zone with wet protection zone
Size Art.-No. Size Art.-No.
medium 02 221 medium 02 227
large 02 225 large 02 228
extra large 02 226 extra large 02 229
xx-large 02 256 xx-large 02 259
Art.-No. 02 357
Available Materials
Size 100 x 150 cm
Aperture oval 6 x 8 cm
■ DS2
Pcs./Pack 1
Two layer laminated material
Upper layer: absorbent viscose 28 g/sqm
Under layer: impervious polyethylene foil
25 µm, for medium fluid procedure.
■ DS3
Three layer laminated material
0481 Upper layer: absorbent viscose 28 g/sqm
Med IIa Intermediate layer: impervious polyethylene
foil 25 µm. Under layer: absorbent non- Surgical Drapes, sterile
Surgical Drapes, sterile woven textile, for high fluid procedure
For Patients and Inventory
Size Dimension Art.-No. Unit For Patients and Inventory
■ SMS Material: PF2, 2-layered laminated material,
0 10 x 55 mm 02 640 1 Pair Material: hydrophobic SMS polypropylene Hydrophobic material made of 100% liquid resistant
nonwoven material 50 g/sqm, 3-layered polypropylene non-woven textile Upper layer: absorbent cellulose 20 g/sqm
1 10 x 120 mm 02 644 1 Set material, type: meltblow-spunbond-melt- 50 g/sqm, three layer structure spunbond- Under layer: impervious polyethylene foil
21 25 x 150 mm 02 645 1 Set blown meltblown-spunbond, for low fluid 20 µm
procedure ■ for low fluid procedures
22 25 x 200 mm 02 646 1 Set ■ for low fluid procedures
2 25 x 250 mm 02 641 1 Set
23 25 x 300 mm 02 648 1 Set SURGICAL DRAPES Material: SMS SURGICAL DRAPES Material: PF2
Art.-No. Size (Drape) Adhesive tape Pcs./Pack Art.-No. Size (Drape) Adhesive tape Pcs./Pack
7 25 x 350 mm 02 647 1 Set 02 270 50 x 50 cm - 1 02 290 50 x 50 cm - 1
Packing: 02 271 50 x 70 cm - 1 02 291 50 x 70 cm - 1
3 25 x 400 mm 02 642 1 Set 1 pair: 1 set: 02 273 75 x 75 cm - 1 02 294 75 x 90 cm - 1
02 274 75 x 90 cm - 1
4 25 x 500 mm 02 650 1 Set 2 retractor hook covers 1 retractor hook cover
02 283 75 x 75 cm 2.5 x 75 cm 1
02 301 50 x 50 cm 2.5 x 50 cm 1
195 mm 30 mm
200 mm 20 mm
polyethylene Med Is
Surgical Drapes
Material DS3
Adhesive Tape ULTRA SONIC GEL
Art.-No. 02 331
Self-adhesive surgical tape with absorbent Size drape 50 x 70 cm Size Art.-No. Standards:
surface area. Pcs./Pack 1 250 ml bottle 04 210
Art.-No. 02 475 500 ml bottle 04 211
Size 8 cm x 120 cm 1 Liter bottle 04 212
VE 1 5 Liter container 04 213 Med I
Art.-No. 02 334 5 Liter cubitainer 04 214
Material: NV28
Size drape 75 x 90 cm
Art.-No. 02 457
Pcs./Pack 1
Size 5 cm x 30 cm
Pcs./Pack 1
DISPOSABLE NEEDLES
Liquid-proof + absorbent
Softimol
Diameter Length Colour Art.-No.
For adults and children: Four-layer reusable system Disposable Needles Injection
G 25/0.5 mm 42 mm red 03 700
Machine washable underpad with soft surface. Will not crinkle ■ suitable for cyclindric ampule and Luer syringes
when used to avoid pressure points on human skin, which cause ■ with plastic hub, precision safety glued G 27/0.4 mm 42 mm yellow 03 703
wounds. Long lasting quilting seams. Can be boil washed repea- ■ siliconized. For single use 37 mm yellow 03 704
tedly with short drying period in household or professional dryer. ■ three edge lancet-grinding for painless injection 23 mm yellow 03 705
Washing instructions are provided. For use with elderly people, ■ particularly voluminous flow G 30/0.3 mm 23 mm green 03 706
hospital patients, children. Will protect mattresses, chairs and furni- ■ 30 G suitable for intraligamental anesthesia 13 mm green 03 707
ture from soiling. ■ easy mounting of the needles due to 10 mm green 03 708
Standard:
0482
Med IIa
STERILE R
WASTE REMOVAL
Available in different kinds of sizes SAFETY CONTAINERS
and shapes. Suggested for syringes, Volume Art.-No.
scalpels, etc. for safe disposal. With 0.25 Litre 04 926 pocket-size
Disposable Syringes different kinds of lids. Securely 0.5 Litre 04 921 standard lid
lockable for transportation and 1.5 Litre 04 922 standard lid
Luer (Slip) two part disposable syringe with- disposal. Comply to UN and ADR 2.2 Litre 04 918 standard lid
out needle. 2 ml syringe with centred tip, standards. 3.5 Litre 04 923 standard lid
5-20 ml offset tip. Transparent barrel with Autoclavable, sticker-free. 4.0 Litre 04 929 standard lid
easy-to-read accurate calibration lines. 6.0 Litre 04 927 standard lid
Non-toxic material, free from latex, PVC For fixtures to table tops, bra- 6.0 Litre 04 924 with flap
Volume 0.25 Litre
and pyrogen. Single blister packed. Sterile. ckets or trolleys: please ask for 11 Litre 04 928 standard lid
Height: 130 mm
Standard: Lid: 80 mm x 45 mm separate leaflet. 11 Litre 04 925 with flap
0434 Packing: 200 pcs./carton
Med IIa
4.000 pcs./pallet
LUER (SLIP)
Volume Art.-No.
2 ml 03 102
5 ml 03 105
10 ml 03 110
20 ml 03 120 Volume 0.5 Litre Volume 1.5 Litre Volume 2.2 Litre
Height: 157 mm Height: 152 mm Height: 204 mm
Lid dia.: 86 mm Lid dia.: 145 mm Lid dia.: 145 mm
Packing: 100 pieces/box Packing: 100 pcs./carton Packing: 90 pcs./carton Packing: 70 pcs./carton
2 ml: 2,000 pieces/outer carton 2.000 pcs./pallet 1.080 pcs./pallet 840 pcs./pallet
5 ml / 10 ml: 1,200 pieces/outer carton
20 ml: 700 pieces/outer carton
Disposable Syringes
Luer (Lock) tip. Two part disposable syringe.
Without needle. Manufactured to ensure
the perfect mating of barrel and plunger.
Non-toxic material, free from latex, PVC
and pyrogen. Single blister packed. Sterile.
SängerPlast SängerPlast
Cotton Roll Plaster Minis
Cotton tape, strong fixation, air permeable. Skin coloured fixing
tape. 100% cotton. SängerPlast Cotton Roll Plaster is tearable in
High performance first aid strips. Skin col- MINIS
our, skin friendly, air permeable. Cotton, for Size Art.-No.
length and width, without a scissor. Radiotransparent. Non-sterile.
quick and reliable application. 250 pieces 20 x 40 mm 03 489
loose packed per box with lid. Specially Packing:
suitable for blood sampling, injections, small 250 pieces per box
COTTON PLASTER wounds etc. Non-sterile. 20 boxes per outer carton
Size Art.-No. Rolls Boxes per
per box outer carton
1.25 cm x 9.14 m 03 532 24 10
2.5 cm x 9.14 m 03 533 12 10 Med I
5 cm x 9.14 m 03 534 6 10
Med I
SängerPlast
SängerPlast Pore Maxis
MAXIS
Art.-No.
Air and steam permeable tape, hypoallergenic for delicate skin i.e. 03 402
children and elderly, neck, face etc. Easy removal. Micro porous High performance first aid strips. Skin col- Contents:
structure allows the skin to breathe. Can be easily torn by hand. our, individually wrapped. Hypoallergenic 20 x 70 mm 150 pcs.
Radiotransparent. Non-sterile. adhesive avoids any skin irritation. 200 in- 20 x 60 mm 30 pcs.
dividually packed waterproof plaster strips, 20 x 40 mm 20 pcs.
non-sterile in a box with lid. Pad will not Packing:
PORE adhere to the wound surface. Non-sterile. 200 pieces per box
Size Art.-No. Rolls Boxes per 51 boxes per outer carton
per box outer carton
1.25 cm x 9.14 m 03 522 24 10
2.5 cm x 9.14 m 03 523 12 10 Med I Med I
5 cm x 9.14 m 03 524 6 10
SängerPlast Sensitive
Sensitive, for sensitive skin,
Sport-Tape painless removing
For non elastic tape bandages to stabilise joints and Hypoallergenic wound plaster for delicate
prevent sports injuries from all kinds of exercises. skin sections such as face skin, neck, skin
The tape can be torn without scissors lengthwise of children and elderly etc. Good adhesive,
and across. Adheres well to skin and other surfaces air permeable and no skin irritations. Air
and does not easily come off, even under sweaty permeable through cell structure of the ma- SENSITIVE
or wet conditions. Does not leave trace particles terial. Easy removing. Pad does not stick to Size Art.-No.
behind when being removed from skin or from the wound surface. Hypoallergenic adhesive 6 cm x 5 m 03 465
other surfaces i.e. guards, socks, shoes, etc. CE Med I
avoids any skin irritation. Radiotransparent. Packing:
Made of 100% cotton with zinc-oxide-adhesive. Roll can be cut to individual sizes. Non- 1 roll per box
Tested for anti-allergenic and non-irritational prop- sterile. 24 boxes per outer carton
erties. Water resistant.Ideal for use as functional
supporting bandage. Prevents sprains and protects
from injuries during recovery period. Can be used
in the treatment of luxations and is used as protec-
tive measure from injuries during sports activities.
SPORT-TAPE For Pre-Tape refer to page 53. Lister Scissors for Bandages
Colour Size Art.-No. Rolls/box Rolls/carton First aid scissors according to DIN 58 279
white 2.5 cm x 10 m 03 481 18 432 suitable for hospitals, doctors practises, first
white 3.8 cm x 10 m 03 480 12 288 aid services, emergency sets and boxes etc.
white 5 cm x 10 m 03 560 6 60 The classical bandage scissor is made of LISTER SCISSORS
blue 2.5 cm x 10 m 03 483 18 432 stainless steel for professional use. Art.-No.
blue 3.75 cm x 10 m 03 482 122 88 03 621
yellow 3.75 cm x 10 m 03 501 12 288
skin 3.75 cm x 10 m 03 503 12 288 Packing:
red 3.75 cm x 10 m 03 505 12 288 200 pieces per outer carton
Med I
HAFT-O-FLEX 2
3 2 1
Size Art.-No. Rolls/Box
CLASSIC COTTON HAFT-O-MULL 1 Med I 2.5 x 450 cm 15 320 60
Size Art.-No. Size Art.-No. Rolls/Box 5 x 450 cm 15 321 36
0.5 m x 6 cm 03 471 4 x 400 cm 15 370 12 7.5 x 450 cm 15 322 24
1 m x 6 cm 03 470 10 x 400 cm 15 373 12 10 x 450 cm 15 323 18
Packing: Art.-No. 03 471: 100 polybags per box
Packing: Packing:
Med I Art.-No. 03 470: 50 polybags per box Individually packed in PP-bag. Individually packed in PP-bag.
Mixed colours per carton. Mixed colours per carton.
Quantities per above table in strong, white carton with flap-lid. Quantities per above table in strong, white carton with flap-lid.
HAFT-O-DESIGN 2 HAFT-O-VET 2
Size Art.-No. Rolls/Box Size Art.-No. Rolls/Box
5 x 450 cm 15 351 36 5 x 450 cm 15 311 36
10 x 450 cm 15 353 18 10 x 450 cm 15 313 18
K A LT-WASSE
Therapie
• Bew in • O ie
keit ediz Therap
Kältekompresse nicht anwenden bei: tbar ortm ive
e hal ie • Sp perat
KO M P R E
Arteriellen Durchblutungsstörungen, Raynaud-Syndrom
• E xtrem th erap • Posto
hig ys io hilfe o C)
Anwendung Kältekompresse: Ins Gefrierfach oder
Kühltruhe (bis 10o C) ef ri erfä
ic h e: Ph Erste rom is 10
g in d he (b n
ger The adjustable velcro seal closure allows flexibility. Replacement cool pads can be
12 x 29 cm 03 633 ierfäh
ig • Exnik und Praxis
Tiefgefr• Bewährt in
Kli
Packing: r
sän placed in the fridge or freezer to provide continuous cold treatment if required.
sänge
Art.-No. 03 631 100 pcs./box 2
Contents per pack: 1 harness with cold-warm pad
Art.-No. 03 632 50 pcs./box
Replacement cold-warm pads available.
Art.-No. 03 633 25 pcs./box Med I
GEL-O-PACK
Description Art.-No.
1 Wrist L/XL 15 382
Replacement gel pads, 2 pcs. / pack 15 383
Tear-Off Colour
white
Art.-No.
03 370
blue 03 371 With blunted edges, has been treated for
Surface layer of strong absorbing paper
TONGUE DEPRESSORS
green 03 372 splinter free surface. Ideal for patient exam-
with under layer of liquid resistant PE-foil to inations, for application of creams and gels,
Art.-No. 03 360
protect the patient’s clothing. For tying at for handling paste and other non-liquid
Size: 50 x 80 cm Packing:
the back. On roll with tear-off perforations substances. Non-sterile.
white 03 373 100 pieces per box
blue 03 374 100 boxes per outer carton
Dispenser for patient`s serviettes green 03 375
white 04 322
Packing size 50 cm x 60 cm:
80 serviettes per roll 6 rolls per carton Med I
Packing size 50 cm x 80 cm:
Med I
60 serviettes per roll 6 rolls per carton
Cellulose Swab
Rubber Hot Water Bottle HOT WATER BOTTLE
Made of high quality rubber with a world-
Colour Art.-No.
Ready to use, pre cut swabs on rolls.
CELLULOSE SWAB
One side ribbed
wide reputation of outstanding quality and Size: 42 x 45 mm. Made of bleached cellu-
red 13 694
safety. 2 Litre rubber hot water bottles from lose according to DIN 19310. Absorb liquid
Art.-No. 03 450
blue 13 693
Sänger’s own production are CE approved. well. Suitable as medium to apply local skin
Packing:
Both sides ribbed
With user and cleaning instruction sheet disinfectant prior to injections or infusions.
2 rolls of 500 pieces per foil pack
red 13 696
in each carton. Many other types and sizes Suitable to clean the skin or to be used as
12 pack per outer carton
blue 13 695
can be supplied. Request for our full hot absorbing material. Non-sterile.
Packing:
water bottle catalogue.
30 pieces per colour in carton with user instructions
Colours: red and blue
Med I Med I
Bags:
Each bag is pre-sealed on three sides and Med I
One-Way Shaver
has a self adhesive edge on the fourth side.
TRAY PAPER
Ideal for standard metal trays. This Colour Art.-No.
filter paper can be used on the white 03 326
Disposable Cups
Med I
2i
material for easy handling. flieder 03 658 Pill cutter with blade in the lid for exact cutting
orange 03 659 of tablets, capsules, pills etc with 3 compart-
light blue 03 661 ments for storage. The pill crusher is situated at
pink 03 662 the opposite end. Crushing is done by tighten- Pill Cutter
Soft and gentle to the skin, giving a luxurious feeling, made of natu-
ral bamboo and viscose fibres for one-way use. Save cost of washing,
drying and ironing. This natural material is bio-degradable. It absor-
7 Day Pill Box bes high degree of moisture and allows the skin to breathe. Will stay
in shape when wet and in use.
Packing:
1 pc. / polybag
250 pcs. per carton
with Braille (letters for blind people) PILL ORGANIZER 7X4 Packing:
Extremely practical pill planer for seven days Art.-No. 03 603 1 pc. / polybag
50 pcs per carton
of removable pill boxes, containing four
Packing:
compartments for each day, stating “morn-
1 piece per blister pack
ing, mid-day, evening, night”. Ideal pill
100 pieces per outer carton
planner for hospitals, homes for the elderly
or handicapped peoples homes. Days de-
scription and Braille letters are available in
German or English language. Marking:
Monday till Sunday and morning, mid day,
evening, night. Standard marking in Ger-
man. English marking is available on re- BATHING TOWEL
quest. Size: 70 x 120 cm, seamless
Art.-No. 04 501
Packing:
ng
Material: Polypropylen
i
EXAM TABLE COVER WITH 2 ELASTIC LOOPS arm
Measurements: Art.-No.
-w
90 x 190 cm 04 510
ling
Packing:
130 Pieces/Carton
protected
coo
German
Patent
Disposable Slippers
ready for use - watertight – breathable
DISPOSABLE SLIPPERS
Disposable Slippers with firm EVA sole and Slipper with firm EVA sole, with covered toes. Compresses have today regained their place as an old, traditional home remedy.
covered toes.
Depending on their purpose, they go back to traditional water treatments or
Size: Length approx. 28 cm
Art.-No. 04 508 ancient herbal knowledge.
Packing: 1 pair per polybag
100 polybags per carton Compresses are applied as home remedy, preventive measure or care when not
feeling well. They work holistically and are invigorating, soothing, cooling or
stimulating - depending on additions and implementation.
Anna‘s Compresses are breathable and waterproof. Thus they can be applied
Disposable Slippers easily and quickly in lowering body temperature by evaporative cooling, witsout
cumbersome moisture protection in bed, which usually does not allow for the
main point: evaporation.
Sänger PRIMA®
Sänger PRIMA®
Sänger PRIMA®
NEOPRENE
NEOPRENE
NEOPRENE
Account No.
NEOTRIL
NEOTRIL
NEOTRIL
NITRILE
NITRILE
NITRILE
LATEX
LATEX
LATEX
VINYL
VINYL
VINYL
Acetic Acid (Food) ++ + ++ ++ Formaldehyde 30% - - - ++ - ++ Pentane - - - - + - -
Acetic Acid concentrated - - - - + Formalin Solution + Perchloric acid 60% ++ ++ ++ ++ Contact
Acetic Acid 50% + ++ Formic Acid - - + - ++ Perchloroethylene - - - - - - - -
Acetic Acid Anhydride ++ ++ = ++ Freon 133 TF - - - - ++ - Perfume & Flavours ++ ++ ++ ++
Acetone - - ++ Freon TMC - - - - - - - - Petrol/Gasoline - - - ++ + Company Name Date
Acetonitrile ++ Fuel Oil - + ++ + Petrolether - - - - ++ -
Acrylates ++ Furfural - - - - - - - - Petroleum Containing
Acrylic Acid ++ - - + - Gamma-Butyrolacetone - - - - - - - - Substances - - - + - Name Phone-No.
Alcohol Based Glycerin - - + ++ ++ Phenol ++
Desinfection Agents ++ Glycerophtali Colours - - - ++ - Phosphoric Acid ++ ++ ++ ++
Alcoholic Drinks ++ ++ ++ ++ Glycole ++ ++ ++ ++ Phosphoric Acid 85% ++
Street / Number Fax-No.
Aldehydes ++ Hair Bleaching Agents ++ ++ ++ ++ Plant Protection Agents + + ++ ++
Ammonium Acetate ++ ++ ++ Hair Dye ++ ++ ++ ++ Potassium Carbonate ++ ++ ++ ++
Ammonium Carbonate ++ ++ ++ Hair Fixing Agents ++ ++ ++ ++ Potassium Hydroxide,
Ammonium Hydroxide (30%) ++ Hair Shampoo ++ ++ ++ ++ KOH, 50% ++ ++ ++ ++ Country / Postal Code / Town e-mail address
Ammonium Nitrate ++ Hexamethyldisilazane - - - - + - - Potassium Nitrate ++ ++ ++ ++
Animal Fats - + ++ ++ Hexane - - - - ++ - - Potassium Permanganate ++ ++ ++ ++
Aqua Regia - - - + ++ Hydraulic Oil - + Potassium Phosphate ++ ++ ++ ++ Delivery address, if different to above address VAT-No.
Acetic Acid, Glacial - - - - + Hydrazine - ++ ++ ++ Potassium Sulphate ++ ++ ++ ++
Battery Acid + + - ++ Hydrochloric Acid 37% ++ ++ Poultry - - - ++ ++
Benzene - - - - - - - Hydrofluoric Acid (48%) ++ Propylene Oxide (99%) + I / We order for delivery:
Benzyl Alcohol - - - - ++ - Hydrofluoric Acid 30% - - - - - - - - Quicklime ++ ++ ++ ++
Description Page Art.-No. Size/ Quantity Price
Bleaching Agents + + ++ ++ Hydrogen Peroxide ++ + ++ - Slaked Lime ++ ++ ++ ++ Colour
Borax ++ ++ ++ ++ Hydrogen Peroxide - ++ ++ ++ Sodium Carbonate ++ ++ ++
Brake Oil - + ++ ++ Hydroquinone + + + + Sodium Chloride ++ ++ ++
Bromine ++ Isobutanole - - - - + + Sodium Dicarbonate ++ ++ ++ ++
Bromide - - ++ ++ Isobutyl Ketone - - - - - - - - Sodium Hydroxide 50% ++ ++
Bromopropionic Acid - - - + Isooctane - - - - ++ - Sodium Hydroxide,
Butoxyethanol + - ++ ++ Isopropyl Alcohol - - - - ++ + ++ concentrated ++ + ++ ++
Butter - - - ++ ++ Kerosene - + ++ + Sodium Hydroxide,
Butyl Acetate - - - + Lactic Acid 85% ++ ++ ++ ++ NaOH (50%) ++ ++ ++ ++ ++
Butylene ++ Linseed Oil - - - ++ ++ Sodium Hypochlorite ++ ++ ++ ++
Calcium chloride ++ ++ ++ ++ Lubricating Oil - - - ++ - Stoddard Solvent - - - - ++ -
Calcium Hydroxide ++ ++ ++ ++ Magnesium Oxide ++ ++ ++ ++ Styrene -
Ethidium Bromide ++ Paraffin Oil - - - ++ - It merely serves as orientation aid. Protection against chemicals
and substances is always depending on many factors, i.e. glove
Ethyl Acetate - +
Fertilizer ++ ++ ++ ++
Peanut Oil
Pentachlorophenol
- - - ++ ++
- - - ++ +
material, contact time, temperature etc. Disposable gloves usually
provide a very limited protection against chemicals.
Sänger Fax-No.: + 49 (0) 79 35/72 24 - 199
All details about the prices and payment terms correspond to the quotation from Sänger GmbH and their terms and conditions