Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
BATTERY
DEEP SEA ELECTRONICS PLC
CHARGER
Issue 2
VH 5/7/01
DESCRIPTION
The model 5100 series 3 Amp and 5 The electronic control circuit ensures
Amp battery chargers are designed that the charger can remain operating
for permanent connection to during engine cranking and running,
automotive batteries, maintaining operating in parallel with the charge
them in a fully charged condition alternator where necessary.
without overcharging. The chargers The charger features a boost charge
are also capable of rapidly facility to enable rapid recharging of
recharging the batteries at a current discharged batteries or to allow
up to the full rated output. The periodic equalisation of battery cells.
charger may also be used to supply When the ‘boost mode select’
a standing load attached to the terminals are connected together the
battery. The charger output may be charger output will rise by 0.35V per
factory set to account for the cell.
standing load. SPECIFICATION
The charger is designed for
reliability, ease of installation and
CAUTION! DC OUTPUT:
accessibility during routine servicing.
12 V DC or 24V DC Nominal
It features radio frequency
Boost mode must only be used in (specified on ordering)
suppression and its smooth output
accordance with the battery AC INPUT:
linear mode design has a low ripple
manufacturers instructions 220 - 250 V AC 50/60Hz
voltage making the charger suitable
otherwise cell damage or an (Specified on ordering)
for use with electronic equipment. OUTPUT CURRENT:
increased maintenance
The charger has both Overload and requirement will occur. 3Amps or 5Amps electronically
Short Circuit protection features, limited
achieved by limiting the current to a (specified on ordering).
OPERATING TEMPERATURE
safe value during these conditions. It
RANGE:
will automatically recover after the
-10 to +60oC
condition is removed.
INDICATIONS:
‘Charger On’ LED.
If a short circuit or a severe overload PROTECTIONS:
is applied such that the voltage falls Short Circuit, Over Voltage,
below four volts for longer than 10 Over-current, Reverse Polarity,
seconds, then the Charge Fail Reverse Power
Alarm relay will energise and the BOOST MODE:
charge fail contact will close. +0.35V per Cell above Float
If the charger is inadvertently reverse voltage.
OPERATION:
connected to the battery then the
The charger will supply current
fuse-link on the circuit board will
to the battery until the battery
rupture. This should be replaced
terminal voltage is equal to the
with a 10A quick blow type. set float voltage, at which point
only a trickle charge current is
present. When the battery
NOTE voltage falls due to a load being
applied and the battery being
The ‘Charger On’ LED will discharged, the charger will
once again supply current to
illuminate even if the fuse has
restore the voltage of the battery
ruptured.
to the float voltage.
CASE DIMENSIONS
RL1
F1
D3 VR2 VR1
120.0 132.0
LK1-3* 146.0
R2**
107.0
90.0 * Linked for 12V
118.0 ** Removed for 3A
123.0
TYPICAL CONNECTIONS
AC MAINS SUPPLY
R2** D3
CHARGE FAIL WARNING
CLOSING ON FAULT
VR2 RL1
BOOST MODE SELECT
VR1
CLOSE FOR BOOST
+Ve DC OUT
F1
LK1-3*
-Ve DC OUT
- +