Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
—
11-12 APRIL, 2019
Green Transformers
Digitalization
Shunt reactors
TXpand™ – A rupture resistant transformer solution
Maintenance free transformers
HVDC – taking new steps in technology
Phase Shifting Transformers
—
Green Transformers
Ester Filled Power Transformers
Synthetic Ester Natural Ester
• Suitable for breathing & sealed transformers • Used in sealed transformers (poor oxidation stability)
• Suitable for cold climate • Not recommended to be used where the ambient
• Low maintenance temperature goes below – 10°C
• Readily biodegradable • Require more cooling equipment (higher viscosity)
Application
ABB References
o For more than 20 years ester fluids are used in ABB transformers
o Over 10 000 distribution transformers globally sold or retrofitted with
ester liquids since 1999
o More than 300 power transformers produced and in operation
o Up to 400 kV voltage class produced and ready for higher levels
4 - Together
Collaborate, advice, transform, re-think
Expert
Services Service Oil Engineering HV Training Consultancy
Agreements Analysis Studies Testing
3 - Do better
Asset
Management Optimize, simulate, predict, automate
Solutions
ABB Ability™ Ellipse® APM
Asset Performance Management
2 - Do more
Monitoring and Automate, monitor, control, secure, manage
Diagnostics
CoreSense Hub CoreTec 4
software Transformer Monitoring
Platform
1 - Know more
Sensor Technologies Assess, connect, store, inform, measure
- Up to around 525 kV
- Up to around 300 Mvar 0.3
110
§ A new and advanced application based on proven technology 525
- Same OLTC as in transformers, same number of steps
- Main- and regulation windings similar to transformers 0 100 200 300 400 500
- Requires high design competence
1 Transformersmagazine
© Copyright 2019 ABB. All right reserved.
April 22, 2019 Slide 9
Reproduction, use or disclosure to third parties without express authority is strictly forbidden.
—
TXpand™ – A rupture resistant transformer solution
Video
Over 70 units delivered to Canada (Hydro 1Ph, 570 MVA 400/24 kV for EDF during 3-ph 150 MVAr/400 kV Shunt Rector for
Quebec main customer and development testing at ABB Transformer factory in Singapore Power during testing at ABB
partner, Hydro One, BC Hydro and to the Cordoba, Spain Transformer factory in Chongqing, China
States (Dow Chemical, PSE&G)
Proven design and production experience with ~ 50 designs and 90 units delivered
It is a unique solution to guarantee that any moisture can get into the transformer conservator with two tanks that work alternatively:
complete isolation between the tank under regeneration and the transformer conservator
It increases reliability and reduces total cost of ownership
Status at-a-glance with colored LED interface No environmental impact for silica-gel disposal
1954
2018
Changji – Guquan +/- 1100kV DC
UHVDC transmission link,
12.000MW and 1100kV DC
G P L
Transmission angle difference fS - fL drives power flow with
unbalanced load sharing of lines. G
A heavy loaded line may limit the total transmission capacity of
G L
the corridor.
P G
• Green transformers
• Esters, lower losses
• Fire safety
• Digitalization
• TXpand™ – A rupture resistant transformer solution
• Reduced maintenance
• Self dehydrating breather
• Vacuum tap changers
• RIP bushing
• UHVDC
• Up to 1100 kVdc
• Up to 12 GW
• Phase shifting Transformers
• Power flow control