NOTE: System must be offline in order to access Transceiver Manager Tools. BASIC OPERATOR TASKS Bind Transceiver Bind transceiver and hard drive prior to operations to enable access to the network. Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ Bind Unbind Transceiver Unbind transceiver and hard drive prior to removal and replacement of transceiver or hard drive. CAUTIONS Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ Unbind • Operators must unbind CAUTION: Transceivers should not be stored or shipped in an unbound state transceiver from hard drive prior to swapping ADVANCED OPERATOR TASKS hard drives. Failure to unbind will result in a Zeroize Transmission Keys loss of communications. Zeroize Transmission Keys upon notification from chain of command, shipping, or • Transceivers should not storing the transceiver. be stored or shipped in Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ Advanced Æ Zeroize the unbound state Transmission Keys Æ Continue Æ Now • A destroyed transceiver Destroy Transceiver cannot be recovered by Destroy transceiver if offline and “Destroy FBCB2” is not accessible. Hard Drive the operator or unit level must be physically destroyed. maintenance. It must be Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ Advanced Æ Destroy turned in through Transceiver Æ Continue Æ Now maintenance. CAUTION: This procedure not recoverable by unit. FOUO FOUO
KEY MANAGEMENT PROCEDURES
HELP DESK NOTE: System must be offline in order to access Transceiver Manager Tool. Each key type is unique & linked to transceiver by transceiver serial number. SIPR mail: bfthelp.conus@us.army.smil.mil Email: bfthelp.conus@us.army.mil Commercial CONUS: 732-427-2979 DSN: 312-987-2979 Secondary: BFT Global Network Operations Center (BGN) Primary: Contact Unit Level Maintenance/FBCB2 FSR 1. Transit Key: Changes transceiver state from Transit to Bound via Set Up. Request key by transceiver serial number from Unit S6/BGN. • Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ Set Up • Input 20 character alpha numeric transit key • Select Enter 2. Escrow Key: Enables transceiver to go from Bound (old harddrive) to Unbound. Required when a bound transceiver is paired with a new hard drive. Request key by transceiver serial number to Unit S6/BGN. • Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ OK Æ Unbind Æ OK • Input 30 character alpha numeric escrow key • Select: Continue Æ OK Æ Bind If transceiver has been zeroized, contact Unit Level Maintenance Personnel for recovery. Transmission Key: Changes transceiver from Zeroized to Bound. Request key by transceiver serial number to S6/BGN via AKO email (for individual key) or AKO SIPR (for multiple keys). The MDL external device can host multiple keys. CAUTION: Drag and drop the folder, as named, into root directory of MDL external device. • Load key to MDL from email attachment received from BGN • Connect MDL to FBCB2 • Select: Start Æ FBCB2 Æ Transceiver Manager Tools Æ OK Æ Advanced Æ HELP DESK Load Transmission keys Æ Continue NOTE: Could take up to 15 minutes before confirmation of successful completion. FOUO