Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1
Table of Contents
CONTENT ................................................................................................................................ 2
Output menu......................................................................................................... 7
2
1. Creating a New Vision Program Number (New Package)
1.1. (Go to Vision screen by click – Ctrl + ~` PS3) Scrolls lock 4 / 5
1.2. Switch the Remote Control Console to “PROG “mode to start Program
3
2. Camera palette title menu
2.3 Click - Escape button Remote Control Console return to previous screen.
3. Global Menu title Bar
3.1 Select – “Run Screen Update Mode “then select “Continuous-A” or “Trigger”.
Continuous – Vision light turn on continuously. -> Then go to run mode to view
life image
Trigger – Vision light Trigger On/Off during Production Mode.
3.3 Click - Escape button Remote Control Console return to previous screen.
4
4. Register palette title menu
5
5.3 Select – W000:AreaToolArea)
The following measurement results are output in the Area measurement tool.
• Target Area: Area output in pixels. (Available in the limits menu)
• OK/NG: If the measurement value exceeds the specified tolerance (upper and lower
limit), an [NG] message is displayed. If it is within the specified tolerance, an [OK]
message is displayed.
• Measurement Area Position: Outputs the measurement window position in pixels
(available as a reference after calculation) Note that polygon measurement window
information is not output
5.6 Select – OK
5.7 Click - Escape button Remote Control Console return to previous screen.
5.8 Select – Search Area (! W000: Area)
5.12 Select – Draw > Exit > Select CLOSE and Select OK.
5.13 Select – Image Enhance > Check Filter ON by clicking on the BOX. (Detect
white)
5.14 Select – BINARY > Detail > Select UPPER & LOWER
BASE value Image will capture, set a Threshold and create a binary (Black &
white) Image.
7
5.18 Set the Upper and Lower Limit (+30~40% for Upper Limit and -30~40% for
Lower limit, both setting are referring to Base Value).
5.19 Select – Escape from Remote Control Console to previous menu select OK.
5.20 Select – Escape from Remote Control Console to previous menu.
5.21 Select - Edit Window
8
6. Output palette title menu.
6.2 Select – Add; Judge Value (W000, W001, W002); Total status; Total Count.
9
6.3 Select – Click at Judge Value and select – select all Windows.
6.4 Select – Add again > Click at Total status.
6.5 Select – Add again > Click at Total count.
6.6 Select – OK and OK again to save changes.
6.7 Select – Output Menu from Main screen.
10
8. Run Mode
8.1 Switch the Remote Control Console to “RUN “mode to start Run.
11
12