Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Installation manual
BGX501-899-R02
Copyright © 2016, SIHPL
1.2 Prerequisites
You must meet the following prerequisites in order to successfully install the ConfigView software:
S.No. Description
1 Operating System (Windows Server 2003/ Windows 7/ Windows 8/ Windows
10)
2 Adobe Reader 7.0 or above
3 .NET Framework 3_5 SP1 setup in the Framework folder (Available with the
setup)
4 Microsoft Report Viewer 2008 (Available with the setup)
5 USB Driver (required for establishing communication between devices and
ConfigView)
1.3 Installing ConfigView from Website
To install the ConfigView from the website, do the following:
1. Download ConfigView from http://www.ceweinstrument.se/en/downloads1/sof/ (under ‘Softwares’
section).
2. Unzip the saved file.
3. Install Microsoft dot Net Framework 3.5 Service pack 1 provided with the set up in the Prerequisite
folder or from http://www.microsoft.com/en-in/download/details.aspx.
4. Next install Report Viewer and USB driver from the Prerequisite folder.
Note: Uninstall the old version of ConfigView, if available.
5. Run the setup.exe
7. The following screen prompts you to specify the folder where ConfigView should be installed and
selection of the user type. It is a good practice to install it under the default Program Files folder as
shown below. Select Everyone as the preferred user type. Click Next to proceed.
10. When the installation is complete, a window similar to the one below appears. Click Close to exit the
wizard.
Note:
If you do not see the popup, click the arrow in the taskbar notification area to view hidden icons.
5. Once connected, the device is listed in the Device Manager list. To view the list and update the driver
manually, right -click the Computer icon, and further click Manage.
6. The Computer Management window appears. In the left-hand navigation pane, click the Device
Manager option. A tree view list of relevant items is shown in the right pane.
7. Click the arrow next to the Other devices option to expand the tree view list.
8. The device is listed as CDC RS-232 Emulation Demo. Right-click this item and click the Update Driver
Software option.
10. The installation of the driver software starts. You can view the status on the progress bar.
11. A confirmation message appears after successful installation.
If you do not have sufficient permission to run the ConfigView application, you can run it as an administrator. To
do so, right-click the application exe where it is installed and click the Run as administrator option as shown
below.
4. Click Next.
8. Retain the default location settings and click the Install button.
1.7.2
I cannot see the The device is Check if the DPT100/ If the device is listed, follow steps 8
popup for updating connected but DPT200/ DPT300 to 11 to install/update the driver.
the software driver the popup for the device is appearing in
after I connect the driver update is the Device Manager
device. not shown. list under the Other
devices option.