Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Title: AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Mute Signal Circuit between Stereo Component Amplifier and
Telematics Transceiver; 2014 2016 MY IS200T IS250 IS300 IS350 [04/2013 ]
Mute Signal Circuit between Stereo Component Amplifier and Telematics Transceiver
DESCRIPTION
The DCM (telematics transceiver) sends a mute signal to the stereo component amplifier assembly.
The stereo component amplifier assembly controls the volume according to the mute signal from the DCM (telematics
transceiver).
WIRING DIAGRAM
CAUTION / NOTICE / HINT
NOTICE:
If the DCM (telematics transceiver) has been replaced, perform the DCM Activation procedure using the
Techstream.
Click here
PROCEDURE
1. INSPECT DCM (TELEMATICS TRANSCEIVER)
(a) Measure the voltage according to the value(s) in
the table below.
Standard Voltage:
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 1/3
3/6/2017 AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Mute Signal Circuit between Stereo Component Amplifier and Telematics Transceiver; 2014 2016 MY …
Engine switch
on (ACC)
K6617 (MUTE) Audio system 2.0 V or higher
Body ground playing → Below 1 V
→ Emergency
call mode
Component with harness connected
*a
(DCM (Telematics Transceiver))
PROCEED TO NEXT SUSPECTED AREA SHOWN IN
OK
PROBLEM SYMPTOMS TABLE
NG
CHECK HARNESS AND CONNECTOR (STEREO COMPONENT AMPLIFIER ASSEMBLY DCM
2.
(TELEMATICS TRANSCEIVER))
(a) Disconnect the P24 stereo component amplifier assembly connector.
(b) Disconnect the K66 DCM (telematics transceiver) connector.
(c) Measure the resistance according to the value(s) in the table below.
Standard Resistance:
NG REPAIR OR REPLACE HARNESS OR CONNECTOR
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 2/3
3/6/2017 AUDIO / VIDEO: AUDIO AND VISUAL SYSTEM: Mute Signal Circuit between Stereo Component Amplifier and Telematics Transceiver; 2014 2016 MY …
OK
3. INSPECT STEREO COMPONENT AMPLIFIER ASSEMBLY
(a) Reconnect the P24 stereo component amplifier assembly connector.
(b) Measure the voltage according to the value(s) in
the table below.
Standard Voltage:
K6617 (MUTE) Engine switch
2.0 V or higher
Body ground on (ACC)
Front view of wire harness connector
*a
(to DCM (Telematics Transceiver))
OK REPLACE DCM (TELEMATICS TRANSCEIVER)
REPLACE STEREO COMPONENT AMPLIFIER ASSEMBLY
NG
https://techinfo.toyota.com/t3Portal/resources/jsp/siviewer/index.jsp?dir=rm/RM30G0U&locale=en&User=false&publicationNumber=RM30G0U&objType=toc/… 3/3