Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
(You are requested, to use the search button to find answers to your queries / questions before posting one.
It might be possible that your issue has already been discussed and resolved multiple times here)
1) What should be the value for injector port? Is the value reflected in attached screenshot high or low?
3 - The attached videos are from Live Data on Toyota Techstream, just I'm case if this data could be
helpful.
system too lean means there is an uncontrolled air leak into the engine, fix that, it can be a bad intake
gasket, torn intake boot, bad evap valve, bad injectors or a bad MAF sensor.
And what about the injector port value highlighted in attached image. Is it too high or too low for 2SZ FE
1300 engine?
The value is a bit high, thats why its throwing the lean code.
Check total fuel trims, find leaks while watching the short term trim, whatever causes the trim to start
fixing it, thats the cause.
Dont confuse the term injector port. Its injector (in intake port)
You mean this term is not about fuel injector.? But injector in air intake system ?
Also the engine oil turns black rapidly whenever I pour in new engine oil, this has been happening since I
got high fuel consumption issue.
You dont have to say port, we already know that 2sz is port injected not direct injected