Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
1. Identification
Product identifier Solder Seal/Gunk S-C Super Concentrated Degreaser
Other means of identification
SDS number SC3
Part No. SC3, SC5, SC2A
Tariff code 3814.00.5090
Recommended use Degreaser
Recommended restrictions None known.
Manufacturer/Importer/Supplier/Distributor information
Manufacturer
Company name RSC Chemical Solutions
Address 600 Radiator Road
Indian Trail, NC 28079
United States
Telephone Customer Service: (704) 821-7643
Technical: (704) 684-1811
Website www.rscbrands.com
E-mail sds@rscbrands.com
Emergency phone number Emergency Telephone: (303) 623-5716
Emergency Contact: RMPDC (877) 740-5015
2. Hazard(s) identification
Physical hazards Not classified.
Health hazards Skin corrosion/irritation Category 2
Serious eye damage/eye irritation Category 2A
Specific target organ toxicity, single exposure Category 3 narcotic effects
Aspiration hazard Category 1
Environmental hazards Hazardous to the aquatic environment, Category 2
long-term hazard
OSHA defined hazards Not classified.
Label elements
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 1/8
Disposal Dispose of contents/container in accordance with local/regional/national/international regulations.
Hazard(s) not otherwise None known.
classified (HNOC)
Supplemental information None.
3. Composition/information on ingredients
Mixtures
Chemical name Common name and synonyms CAS number %
Alcohols, C11-14-iso-, C13-rich, 78330-21-9 5 - < 10
Ethoxylated
Isopropylamine 26264-05-1 1-<3
Dodecylbenzenesulfonate
Other components below reportable levels 90 - 100
*Designates that a specific chemical identity and/or percentage of composition has been withheld as a trade secret.
4. First-aid measures
Inhalation Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON
CENTER or doctor/physician if you feel unwell.
Skin contact Remove contaminated clothing. Wash with plenty of soap and water. If skin irritation occurs: Get
medical advice/attention. Wash contaminated clothing before reuse.
Eye contact Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses, if
present and easy to do. Continue rinsing. Get medical attention if irritation develops and persists.
Ingestion Call a physician or poison control center immediately. Rinse mouth. Do not induce vomiting. If
vomiting occurs, keep head low so that stomach content doesn't get into the lungs.
Most important Aspiration may cause pulmonary edema and pneumonitis. May cause drowsiness and dizziness.
symptoms/effects, acute and Headache. Nausea, vomiting. Severe eye irritation. Symptoms may include stinging, tearing,
delayed redness, swelling, and blurred vision. Skin irritation. May cause redness and pain.
Indication of immediate Provide general supportive measures and treat symptomatically. Keep victim under observation.
medical attention and special Symptoms may be delayed.
treatment needed
General information Ensure that medical personnel are aware of the material(s) involved, and take precautions to
protect themselves.
5. Fire-fighting measures
Suitable extinguishing media Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2).
Unsuitable extinguishing Do not use water jet as an extinguisher, as this will spread the fire.
media
Specific hazards arising from During fire, gases hazardous to health may be formed.
the chemical
Special protective equipment Self-contained breathing apparatus and full protective clothing must be worn in case of fire.
and precautions for firefighters
Fire fighting Move containers from fire area if you can do so without risk.
equipment/instructions
Specific methods Use standard firefighting procedures and consider the hazards of other involved materials.
General fire hazards No unusual fire or explosion hazards noted.
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 2/8
Methods and materials for Prevent entry into waterways, sewer, basements or confined areas.
containment and cleaning up
Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is
possible. Absorb in vermiculite, dry sand or earth and place into containers. Following product
recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Environmental precautions Avoid release to the environment. Inform appropriate managerial or supervisory personnel of all
environmental releases. Prevent further leakage or spillage if safe to do so. Avoid discharge into
drains, water courses or onto the ground.
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 3/8
Flammability limit - upper 8.5 % estimated
(%)
Explosive limit - lower (%) Not available.
Explosive limit - upper (%) Not available.
Vapor pressure 0.03 hPa estimated
Vapor density Not available.
Relative density Not available.
Solubility(ies)
Solubility (water) Not available.
Partition coefficient Not available.
(n-octanol/water)
Auto-ignition temperature 530.6 °F (277 °C) estimated
Decomposition temperature Not available.
Viscosity Not available.
Other information
Density 7.40 lbs/gal
Explosive properties Not explosive.
Flammability class Combustible IIIB estimated
Moisture < 0.5 % w/w
Oxidizing properties Not oxidizing.
Percent volatile 0.74 % estimated
Refractive index 1.47
Specific gravity 0.89
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 4/8
Germ cell mutagenicity No data available to indicate product or any components present at greater than 0.1% are
mutagenic or genotoxic.
Carcinogenicity Not classifiable as to carcinogenicity to humans.
IARC Monographs. Overall Evaluation of Carcinogenicity
Not listed.
OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050)
Not regulated.
US. National Toxicology Program (NTP) Report on Carcinogens
Not listed.
Reproductive toxicity This product is not expected to cause reproductive or developmental effects.
Specific target organ toxicity - May cause drowsiness and dizziness.
single exposure
Specific target organ toxicity - Not classified.
repeated exposure
Aspiration hazard May be fatal if swallowed and enters airways.
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 5/8
Other information
Passenger and cargo Allowed with restrictions.
aircraft
Cargo aircraft only Allowed with restrictions.
IMDG
UN number UN3082
UN proper shipping name ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (Alcohols, C11-14-iso-,
C13-rich, Ethoxylated), MARINE POLLUTANT
Transport hazard class(es)
Class 9
Subsidiary risk -
Packing group III
Environmental hazards
Marine pollutant Yes
EmS F-A, S-F
Special precautions for user Read safety instructions, SDS and emergency procedures before handling.
Transport in bulk according to Not established.
Annex II of MARPOL 73/78 and
the IBC Code
IATA; IMDG
Marine pollutant
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 6/8
Superfund Amendments and Reauthorization Act of 1986 (SARA)
Hazard categories Immediate Hazard - Yes
Delayed Hazard - No
Fire Hazard - No
Pressure Hazard - No
Reactivity Hazard - No
SARA 302 Extremely hazardous substance
Not listed.
SARA 311/312 Hazardous No
chemical
SARA 313 (TRI reporting)
Not regulated.
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 7/8
Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge,
information and belief at the date of its publication. The information given is designed only as a
guidance for safe handling, use, processing, storage, transportation, disposal and release and is
not to be considered a warranty or quality specification. The information relates only to the specific
material designated and may not be valid for such material used in combination with any other
materials or in any process, unless specified in the text.
Revision information This document has undergone significant changes and should be reviewed in its entirety.
SC3, SC5, SC2A Version #: 03 Revision date: 05-03-2017 Issue date: 06-08-2015 8/8