Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
SKILL ACCESS
MECH. INSP.
** ON A/C ALL
TASK 24-00-00-810-818-A
Computer Reset
1. Possible Causes
2. Fault Confirmation
Subtask 24-00-00-710-059-A
A. Test
(1) Not applicable
3. Fault Isolation
Subtask 24-00-00-865-051-A
A. Table of the circuit breakers used in this procedure:
EFF : Page 1 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
EFF : Page 2 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
** ON A/C ALL
Subtask 24-00-00-810-069-A
B. Computer reset procedure
NOTE: This reset procedure is used when a computer does not operate correctly.
EFF : Page 3 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
NOTE: The line maintenance personnel can use it a first time to avoid a computer replacement (a reset
must be done for the applicable computer as indicated in the Computer Reset Table).
But, if there is more than one reset for each flight cycle for a given computer, it is necessary to do
the specific troubleshooting procedure for the applicable system.
If after a reset, the computer operates correctly, no more action is necessary.
EFF : Page 4 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
EFF : Page 5 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
Subtask 24-00-00-810-077-B
E. Communications
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
23 COM CIDS 1+2 FAULT CIDS - Open the C/Bs in this
order:
on the panel 49VU, C/B 150RH
on the panel 121VU, C/B
151RH
on the panel 49VU, C/B 157RH
on the panel 121VU, C/B
156RH
- After 10 seconds, close
the C/Bs in this order:
EFF : Page 6 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
** ON A/C ALL
Subtask 24-00-00-810-088-A
F. Electrical Power
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
24 GPU cannot be connected GAPCU If at least one power source
to the aircraft (IDG 1 or IDG 2, APU GEN or
batteries) is connected to
the electrical network of
EFF : Page 7 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
the aircraft:
- On the ELEC control panel
35VU:
. Push and release the
EXT PWR pushbutton
switch.
If no power source is
connected to the electrical
network of the aircraft:
- On the ELEC control panel
35VU:
. Push the BAT 1 and BAT 2
pushbutton switches
(the OFF legend goes
off).
Subtask 24-00-00-810-078-A
G. Fire Protection
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
26 SMOKE LAV + CRG DET FAULT SDCU On the panel 49VU:
- open the C/B 11WQ
On the panel 122VU:
- open the C/B 12WQ
After 10 seconds, close the
two C/B's.
26 ENG1(2) LOOP k FAULT ENGINE FDU On the panel 49VU:
- For ENG1 FDU, open the
C/B 7WD1.
- For ENG2 FDU, open the
C/B 8WD2.
On the panel 121VU:
- For ENG1 FDU, open the
C/B 8WD1.
- For ENG2 FDU, open the
C/B 7WD2.
- After 5 seconds, close
the C/Bs.
26 APU FIRE LOOP k FAULT APU FDU On the panel 121VU:
- Open the C/Bs 2WG and 1WG.
- After 5 seconds, close the
C/Bs.
** ON A/C ALL
EFF : Page 8 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
Subtask 24-00-00-810-079-A
H. Flight Controls
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
27 F/CTL ELAC 1(2) FAULT ELAC Reset the defective ELAC:
F/CTL ALTN LAW FAULT - Make sure that the
hydraulic systems are
depressurized before the
reset.
- Set the ELAC pushbutton
switch to OFF, then to ON.
27 ELAC or SEC malfunction ELAC or SEC Reset the defective ELAC:
- Make sure that the
hydraulic systems are
depressurized before the
reset.
Open, then close the C/B of
the defective ELAC or SEC.
For the ELAC 1(2):
- On the panel 49VU, C/B
15CE1.
- On the panel 121VU, C/B
15CE2.
For the SEC 1(2)(3):
- On the panel 49VU, C/B
21CE1.
- On the panel 121VU, C/B
21CE2 or 21CE3.
27 E/W FCDC1(2) FAULT FCDC On the panel 49VU:
- For FCDC1, open the C/B
20CE1.
- For FCDC2, open the C/B
20CE2.
- After 5 seconds, close
the C/Bs.
Subtask 24-00-00-810-089-A
J. Fuel
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
28 Loss of fuel quantity FQIC On the overhead circuit
indication or, breaker panel 49VU:
Simultaneous triggering - Open the C/B 1QT.
of FUEL L XFR VALVE On the rear circuit
CLOSED and FUEL R XFR breaker panel 121VU:
VALVE CLOSED, although - Open the C/B 2QT.
EFF : Page 9 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
EFF : Page 10 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
EFF : Page 11 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
position.
- Wait for more than five
seconds.
On the ECAM control panel
turn the UPPER DISPLAY
potentiometer from the
OFF position to the BRT +
position.
31 SD malfunction SD On the ECAM control panel
turn the LOWER DISPLAY
potentiometer from the
BRT position to the OFF
position.
- Wait for more than five
seconds.
On the ECAM control panel
turn the LOWER DISPLAY
potentiometer from the
OFF position to the BRT
position.
Subtask 24-00-00-810-082-A
M. Landing Gear
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
32 Braking malfunction BSCU On the panel 121VU:
- open the C/Bs 1GG, 2GG,
3GG and 4GG
- after 5 seconds, close
the CB's
32 L/G LGCIU 1(2) FAULT LGCIU 1(2) For the LGCIU 1:
- on the panel 121VU, open
the C/B 52GA then on 49VU,
C/B 1GA. Then close the
C/B 1GA and C/B 52GA
For the LGCIU 2:
- on the panel 121VU, open
then close the C/B 2GA.
Subtask 24-00-00-810-083-A
N. Navigation
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
34 NAV MMR 1(2) FAULT MMR1(2) For the MMR 1:
- On the panel 49VU, open
the C/B 42RT1.
EFF : Page 12 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
Subtask 24-00-00-810-084-A
P. Water/Waste
(1) Computer Reset Table
ATA SYSTEM MALFUNCTION COMPUTER RESET PROCEDURE
38 Fault messages on the Vacuum On the panel 2001VU:
FAP in the cabin System - open the C/B 35MG
Controller - after 30 seconds, close
the C/B.
** ON A/C ALL
Subtask 24-00-00-810-085-A
Q. Information Systems
EFF : Page 13 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time
JOB CARD MPD-TASK :
JKK - A318/A319/A320/A321 TSM TASK :
24-00-00-810-818
TITLE: 24-00-00 PB 201
24-00-00-810-818-A - Computer Reset
A/C Reg.:
AP-BLJ, AP-BLK
EFF : Page 14 of 14
DATABASE REV DATE : May 1, 2013
PRINT DATE : July 13, 2013 Local Time