Documenti di Didattica
Documenti di Professioni
Documenti di Cultura
Kananga, Leyte
I. Multiple Choice. Read the question carefully. Encircle the letter of your correct answer.
1. Made from a variety of materials, such as carbon, this inhibits the flow of current.
a. inductor b. Choke c. Resistor d. Capacitor
2. This consists of two plates separated by a dielectric and can store a charge. Useful in tuning
and filtering circuits, it blocks DC while passing AC.
a. inductor b. Transistor c. Capacitor d. relay
3. This can consist of a simple wire wound into a helix. It developes a magnetic field when
current passes through it. It is also used in tuning circuits and filters. This one passes DC and
blocks AC.
a. capacitor b. Semiconductor c. Inductor d. transistor
4. This is a type of semiconductor that only allows current to flow in one direction. It is usually
used to rectify AC signals (conversion to DC).
a. diode b. Inductor c. Univac d. transformer
5. This consists of an electromagnet, which is used to open or close a contact(s). It is used in
switching that requires isolation or high power.
a. relay b. Transistor c. Inductor d. rheostat
6. This is a type of semiconductor in which the flow of current can be controlled through a base
or gate terminal. It is usually used for electronic switching or amplifiers.
a. resistor b. Transistor c. Diode d. varistor
7. This consists of usually two coil windings which usually share a magnetic core. It is used to
convert an AC source or signal into another AC source or signal with the same power (ideally)
but different voltage and current.
a. relay b. Transistor c. Transformer d. choke
8. This is a special type of diode that breaks down when a critical reverse voltage is applied. It is
most commonly used to regulate voltage.
a. transistor b. Zener diode c. Anode d. LED
9. This is a special type of diode that lights up when a small voltage is applied. They are usually
used as indicators or in numerical or alphanumerical displays.
a. LED b. incandescent lamp c. Zener diode d. LCD
10. This is a type of display that uses tiny polarized crystals that align when current is passed
through them. Used in conjuction with a polarized lens they darken when energized. They are
very popular in watches, calculators, and lap-tops.
a. LCD b. CRT c. Quartz Crystal d.LED
II. IDENTIFICATION.
A. Identify the following tools/equipment based on the cited uses. Write your on the space
provided.
_____________________ 1. Used to join metals and solder components.
_____________________ 2. Used to strip insulators.
_____________________ 3. Used to hold small components.
_____________________ 4. Used to drill holes on PCB.
_____________________ 5. Used to cut wires.
_____________________ 6. Used to drive screw.
_____________________ 7. Used to cut unnecessary copper on PCB.
_____________________ 8. Used to measure voltage, resistance and current.
_____________________ 9. Produces simple waveforms.
_____________________ 10. Used to view signal.
C. Read the resistance value using resistance (ohms) scale as where the arrow pointing on the meter
scale for every number. Readings may vary depending on what range is used assigned to every
number.
1. Rx1= 6. Rx100K=
2. Rx10= 7. Rx1=
3. Rx100= 8.Rx10=
4.Rx1K= 9.Rx100=
5.Rx100K= 10. Rx1K=
1. SPST
2. RECTIFIER DIODE
3. ELECTROLYTIC CAPACITOR
4. RESISTOR
5. ANTENNA
6. CHASSIS GROUND
7. BATTERY
8.FUSE
9. MICROPHONE
10. LOUDSPEAKER
13. INDUCTOR
14. LED
E. Give the resistance value and tolerance of the following resistor color codes.
PREPARED BY:
HENRY A. SINGCOL